In this study, ethylene-vinyl acetate (EVA) copolymer-based blend foams with polyolefin elastomers (POEs), low-density polyethylene, or styrenic thermoplastic elastomers were prepared as a potential resilient material for reducing inter-floor noise. Various properties of EVA blend foams were measured in order to reveal the effects of EVA content and types of pair polymers consisting of EVA blend foams on dynamic stiffness, which is one of the key factors of resilient materials, in relation to hardness, specific gravity, and resilience. These properties had not been introduced by the construction industry until now. When the EVA/POE ratio was 20/80 and the foaming ratio was 210%, dynamic stiffness presented the lowest value at 5.97 MN m−3. However, when the resilience was <20%, dynamic stiffness was as high as 37.66 MN m−3 at an expansion ratio of 210% even when the specific gravity was low.
Korea Environment Corporation. Report on 2018 operating results of inter-storied noise neighborhood center. Report, Korea Environment Corporation, Korea, January2019.
2.
JeongGCYangGS. A study on the property of the floor impact isolation material in apartment house. J Kor Soc Noise Vibr Eng2001; 2001: 59–64.
3.
LeeJWJeongGCKwonYP. Correlation between dynamic characteristics of isolation material and impact noise reduction of light-weight impact source. J Kor Soc Noise Vibr Eng2003; 2003: 191–195.
4.
BayoumiTATawfikME. Immobilization of sulfate waste simulate in polymer-cement composite based on recycled expanded polystyrene foam waste: evaluation of the final waste form under freeze-thaw treatment. Polym Comp2017; 38: 637–645.
5.
LuXXuMShengY, et al.Preparation of polyurethanes with broad damping temperature range and self-healing properties. J Elast Plast2019; 51: DOI: 10.1177/0095244319863153.
6.
SulongNHRMustapaSASRashidMKA. Application of expanded polystyrene (EPS) in buildings and constructions: a review. J Elast Plast2019; 136: 47529 (1–11).
7.
WypychG. Handbook of foaming and blowing agents. 1st ed. Toronto: ChemTec, 2017, p. 41.
8.
RocheNIchchouMNSalviaM, et al.Dynamic damping properties of thermoplastic elastomers based on EVA and recycled ground tire rubber. J Elast Plast2012; 43: 317–340.
9.
KaewunruenSRemennikovAM. Experimental simulation of the railway ballast by resilient materials and its verification by modal testing. Exper Techniq2008; 32: 29–35.
10.
DevricsAJ. Foam stability. A fundamental investigation of the factors controlling the stability of foams. Rubber Chem Technol1958; 31: 1142–1205.
11.
KS F2868:2003. Determination of dynamic stiffness of materials used under floating floors in dwellings.
12.
KS M ISO 2796:2005. Cellular plastics, rigid—test for dimensional stability.
13.
KS F2810-1:2015. Field measurements of impact sound insulation of floors—part 1: method using standard light impact source.
14.
KS F2810-2:2012. Field measurements of floor impact sound insulation of buildings—part 2: method using standard heavy impact sources.
15.
Ministry of Land, Infrastructure and Transport. Notification no. 2016-824. Apartment housing floor impact sound insulation structure confirmation and management standard 2016.
16.
KimHSKimDHBangM. Dynamic properties of resilient materials for reduction of floor impact sound. J Korean Soc Living Environ Sys2008; 15: 112–122.
17.
ParkKWKimGHChowdhurySR. Improvement of compression set property of ethylene vinyl acetate copolymer/ethylene-1-butene copolymer/organoclay nanocomposite foams. Polym Eng Sci2008; 48: 1183–1190.
18.
VisentiniCBLibermanSAMaulerRS. Glycerol: a promising agent for nanodispersion and compatibility of EVA/organomodified montmorillonite nanocomposites. Poly Adv Technol2015; 26: 287–293.
19.
HeoJY. Expansion behavior and shock absorbing characteristics of ethylene vinyl acetate/styrene vinyl isoprene styrene block copolymers blend. MS Thesis, Pusan National University, Busan, Korea, 2000, pp. 1–90.
20.
KarpFLunaJAMengattoLN. Recyclable amitraz-ethylene vinyl acetate strips used for beehives treatment against varroa destructor. J Elast Plast2018; 50: 391–402.
21.
StarkWJaunichM. Investigation of ethylene/vinyl acetate copolymer (EVA) by thermal analysis DSC and DMA. Polym Test2011; 30: 236–242.
22.
ZhangCWangPMaCA, et al.Damping properties of chlorinated polyethylene-based hybrids: effect of organic additives. J Appl Polym Sci2006; 100: 3307–3311.
23.
LuXHuangRLiH, et al.Preparation of an elastomer with broad damping temperature range based on EPDM/ENR blend. J Elast Plast2017; 49: 759–773.
24.
JeongGHRyuJKLeeJI, et al.Effect of material property of floor impact sound isolator on heavy-weighted floor impact sound level in the apartment building. J Kor Soc Living Environ Sys2014; 21: 19–25.
25.
KimKWJeongGCYangKS, et al.Correlation between dynamic stiffness of resilient materials and heavyweight impact sound reduction level. Build Environ2009; 44: 1589–1600.
26.
BurkeMPSmithJDCarrollNL, et al.Acoustic properties of butadiene and silicone elastomers at megahertz frequencies. Plast Rubber Comp2009; 38: 343–348.
