Frost forms on the surfaces of air source heat pump (ASHP) outdoor heat exchangers under heating mode in winter, when the surface temperature of the heat exchanger is lower than both 0°C and the ambient dew point temperature. This can reduce the coefficient of performance (COP) and heating capacity of the ASHP unit. A novel ASHP was examined using two rooms with the same size, orientation, and structure. To test the frost suppression performance of the novel system, two ASHPs of the same size and specifications, but one including a sensible-heat preheating device, were placed in the test platform rooms. By comparing and analyzing field-measured parameters such as COP, heat loss, and frost weight of the two ASHP units, the frost suppression performance of the novel ASHP was evaluated in severe, moderate, and mild frost areas. The results show that when the air conditions were −3.9°C and 98.7% in the moderate frost area and 3.2°C and 96.7% in the severe frost area, the novel ASHP showed significantly improved performance. The frost formation time increased from 25 min to 38.5 min, frost-defrost heat loss decreased by 31.6%–43.7%, frost weight decreased 11.8%–17.4%, and COP increased 7.4%–13.1% compared with those of the conventional ASHP. In the low temperature and mild frost area, when the air temperature was −11.8°C and the relative humidity was 88.8%, the frost suppression effect of the novel ASHP was unapparent.
Practical application
Affected by the climate, the operation performance of ASHP will be different. Different ASHP can be used to adapt to the weather in different regions. The novel ASHP can significantly suppress frost and improve the heating performance of the unit in the mild climate and frost serious areas.
SongMDengSDangC, et al., Review on improvement for air source heat pump units during frosting and defrosting, Appl Energy211 (2018)1150–1170. DOI: 10.1016/j.apenergy.2017.12.022
2.
AmerMWangCC, Review of defrosting methods, Renew Sustain Energy Rev73(2017) 53–74. DOI: 10.1016/j.rser.2017.01.120
3.
PatilMSSeoJHLeeMY, Heat transfer characteristics of the heat exchangers for refrigeration, air conditioning and heat pump systems under frosting, defrosting and dry/wet conditions—a review, Appl Therm Eng113 (2017) 1071–1087. DOI: 10.1016/j.applthermaleng.2016.11.107
4.
XiongTLiuGWangS, et al.An investigation on the efficient reverse cycle defrosting strategy for microchannel heat exchanger heat pump system. J Build Eng71 (2023) 106537. DOI: 10.1016/j.j.jobe.2023.106537
5.
SongMDengSMaoN, et al., An experimental study on defrosting performance for an air source heat pump unit with a horizontally installed multi-circuit outdoor coil, Appl Energy, 165(2016)371–382. DOI: 10.1016/j.apenergy.2015.12.107
6.
WangZSongMWangF, et al., Experimental investigation and seasonal performance assessment of a frost-free ASHP system with radiant floor heating, Energy Build, 179(2018):200–212. DOI: 10.1016/j.enbuild.2018.09.019
7.
LiuSBaiXZhangL, et al.Developing condensing-frosting performance maps for a variable speed air source heat pump (ASHP) for frosting suppression[J].Appl Therm Eng, 211 (2022) 118397. DOI: 10.1016/j.applthermaleng.2022.118397.
8.
AmeenFRConeyJERSheppardCGW, Experimental study of warm-air defrosting of heat-pump evaporators, Int J Refrig16(1993)13–18. DOI: 10.1016/0140-7007(93)90015-Z
9.
ZhangLSongMMaoN, et al., Temporal and spatial frost growth prediction of a tube-finned heat exchanger considering frost distribution characteristics. Int J Heat Mass Tran, 183 (2022) 122192. DOI: 10.106/j.ijheatmasstransfer.2021.122192
10.
ZhangLSongMHosseiniSH, et al., A modeling study of spatial and temporal frost growth on the edge of windward fins for a tube-finned heat exchanger, Int J Heat Mass Tran, 183 (2022), 122093. DOI: 10.1016/j.ijheatmasstransfer.2021.122093
11.
WangFWangZZhengY, et al., Performance investigation of a novel frost-free air-source heat pump water heater combined with energy storage and dehumidification, Appl Energy139(2015) 212–219. DOI: 10.1016/j.apenergy.2014.11.018
12.
HermesCJLSommersADGebhartCW, et al.A semi-empirical model for predicting frost accretion on hydrophilic and hydrophobic surfaces, Int J Refrig87 (2018)164–171. DOI: 10.1016/j.ijrefrig.2017.09.022
13.
ZhangYNMaQLiBX, et al., Application of an air source heat pump (ASHP) for heating in Harbin, the coldest provincial capital of China, Energy Build, 138 (2017) 96–103. DOI: 10.1016/j.enbuild.2016.12.044
14.
LiangSWangWSunY, et al., Field investigations on frosting uppression for variable-capacity ASHPs through optimizing their operations and configurations, Energy Build224 (2020) 110266. DOI: 10.1016/j.enbuild.2020.110266
15.
HermesCJLSommersADGebhartCW, et al.A semiempirical model for predicting frost accretion on hydrophilic and hydrophobic surfaces, Int J Refrig87 (2018)164–171. DOI: 10.1016/j.ijrefrig.2017.09.022
16.
LiLTWangWSunYY, et al., Investigation of defrosting water retention on the surface of evaporator impacting the performance of air source heat pump during periodic frosting–defrosting cycles, Appl Energy135 (2014) 98–107. DOI: 10.1016/j.apenergy.2014.07.028
17.
ZhangYZhangGZhangA, et al., Frosting phenomenon and frost-free technology of outdoor air heat exchanger for an air-source heat pump system in China: an analysis and review, Energies11 (2018) 2642. DOI: 10.3390/en11102642
18.
ShenJQianZXingZ, et al., A review of the defrosting methods of air source heat pumps using heat exchanger with phase change material, Energy Proc160 (2019) 491-498. DOI: 10.1016/j.egypro.2019.02.197
19.
SongMJChaobinDNingM, et al., Energy transfer procession in an air source heat pump unit during defrosting with melted frost locally drainage in its multi-circuit outdoor coil, Energ. Buildings164 (2018) 109–120. DOI: 10.1016/j.enbuild.2018.01.004
20.
WeiWNiLWangY, et al., Experimental and theoretical investigation on defrosting characteristics of a multi-split air source heat pump with vapor injection. Energy Build217 (2020) 109938. DOI: 10.1016/j.enbuild.2020.109938
21.
QuMLLiTRDengSM, et al., Improving defrosting performance of cascade air source heat pump using thermal energy storage based reverse cycle defrosting method, Appl Therm Eng121 (2017) 728–736. DOI: 10.1016/j.applthermaleng.2017.04.146
22.
LiuZBFanPYWangQH, et al., Air source heat pump with water heater based on a bypass-cycle defrosting system using compressor casing thermal storage, Appl Therm Eng128 (2018) 1420–1429. DOI: 10.1016/j.applthermaleng.2017.09.131
23.
ChoiHJKimBSKangD, et al., Defrosting method adopting dual hot gas bypass for an air-to-air heat pump, Appl Energy88 (12) (2011) 4544–4555. DOI: 10.1016/j.apenergy.2011.05.039
24.
ZhaoRWangZHuangD, et al., Electric-heater defrosting performance of frost-free refrigerator-freezer and its improvement by step-reduction power. Appl Therm Eng226 (2023) 120147. DOI: 10.1016/j.applthermaleng.2023.120147
25.
BansalPFothergillDFernandesR, Thermal analysis of the defrost cycle in a domestic freezer, Int J Refrig33 (2010) 589–599. DOI: 10.1016/j.ijrefrig.2009.11.012
26.
MeloCKnabbenFTPereiraPV. An experimental study on defrost heaters applied to frost-free household refrigerators. Appl Therm Eng51(2013)239–245. DOI: 10.1016/j.applthermaleng.2012.08.044
27.
SongMJDongJKWuCL, et al., Improving the frosting and defrosting performance of air source heat pump units: review and outlook, Trans Hong Kong Inst Eng24(2017) 88–98. DOI: 10.1080/1023697X.2017.1313134
28.
ShangPJ, Effect of pre-start fans on defrosting characteristics of air source heat pump, Refrig Air Cond9 (2009) 54–59. (in Chinese)
29.
TanHXuGTaoT, et al., Investigation on the ultrasonic propagation mechanism and its application on air-source heat pump defrosting, Appl Therm Eng107 (2016) 479–492. DOI: 10.1016/j.applthermaleng.2016.06.185
30.
WangWXiaoJGuoQC, et al., Field test investigation of the characteristics for the air source heat pump under two typical mal-defrost phenomena[J]. Appl Energy88(2011)4470-4480. DOI: 10.1016/j.apenergy.2011.05.047
31.
BaiXXLiuSNDengSM, et al., An experimental study on achieving even-frosting for an air source heat pump using a novel dual-fan outdoor coil. Energy Build255(2022)111695. DOI: 10.1016/j.enbuild.2021.111695
32.
ChungYYooJWKimGT, et al., Prediction of the Frost Growth and Performance Change of Air Source Heat Pump System under Various Frosting Conditions[J]. Appl Therm Eng147(2019)410-420. DOI: 10.1016/j.applthermaleng.2018.10.085
33.
GeYSunYWangW, et al., Field test study of a novel defrosting control method for air-source heat pumps by applying tube encircled photoelectric sensors[J]. Int J Refrig66(2016)133-144. DOI: 10.1016/j.ijrefrig.2015.07.004
34.
ZhangLFujinawaTSaikawaM. A new method for preventing air-source heat pump water heaters from frosting[J]. Int J Refrig35(2012):1327-1334. DOI: 10.1016/j.ijrefrig.2012.04.004
35.
XuBYLuYJMaZL. Heat pump[M]. China Building Industry Press, 1988. (in Chinese)
36.
JiangYQChaiYJYaoY, et al.Research status and progress of refrigeration and air conditioning anti-frosting for air source heat pump units. Refrig Air Cond23 (2009) 1-5. (in Chinese)
37.
KwakKBaiC. A study on the performance enhancement of heat pump using electric heater under the frosting condition: Heat pump under frosting condition[J]. Appl Therm Eng30(2010) 539-543. DOI: 10.1016/j.applthermaleng.2009.10.016
38.
HuangBJianQLuoL, et al., Experimental study of enhancing heating performance of the air-source heat pump by using a novel heat recovery device designed for reusing the energy of the compressor shell[J]. Energy Convers Manag138(2017):38-44. DOI: 10.1016/j.enconman.2017.01.061
39.
DiLZhaoFYTangGF. Frosting of heat pump with heat recovery facility[J]. Renew Energy32(2007)1228-1242. DOI: 10.1016/j.renene.2006.03.019
40.
WangP. An investigation on frost restraint for air source heat pump by using indoor exhaust air energy [D]. PHD of Tianjin University, 2016. (in Chinese)
41.
China Academy of Building Research. GB/T21087-2007 Air- Air energy recovery device [S]. China Standards Press, 2007. (in Chinese)
42.
ZhuJHSunYYWangW, et al., Developing a new frosting map to guide defrosting control for air-source heat pump units[J]. Appl Therm Eng90 (2015)782-791. DOI: 10.1016/j.applthermaleng.2015.06.076
43.
WangWCuiYSunY, et al., A new performance index for constant speed air-source heat pumps based on the nominal output heating capacity and a related modeling study[J]. Energy Build, 184(2019) 205-215. DOI: 10.1016/j.enbuild.2018.12.009
44.
MoffatRJ, Describing the uncertainties in experimental results, Exp Therm Fluid Sci1 (1988) 3–17. DOI: 10.1016/0894-1777(88)90043-X
