In this study, quasi-in-situ electron backscatter diffraction was employed to investigate the microstructural evolution and deformation behaviour of ZK60 magnesium alloy with an initial 45° extruded state orientation under two high-speed impacts. The experimental results demonstrated that the deformation of the alloy mainly depended on slip and tension twinning. With the increase of deformation, the tension twins nucleated continuously, and there were stretching twin variants that were 60° away from the original stretching twins. In addition, compared with the conventional orientation (extrusion direction), 45° samples were easier to activate various slips under high-strain rate deformation conditions, especially ⟨c + a⟩ slips.
LiuYTangPZGongMY, et al.Three-dimensional character of the deformation twin in magnesium. Nat Commun2019; 10: 3308.
2.
ZhouBTaiJLuY, et al.Dislocation-modified high index twinning mechanisms in deformed magnesium alloy. J Alloys Compd2019; 787: 423–428.
3.
KimMHuhH. Asymmetric hardening behavior of AZ31B magnesium alloy sheet with large strain at various strain rates. Int J Automot Technol2019; 20: 645–653.
4.
VasilevEFerreriNCDeckerR, et al.Strain-rate sensitivity, tension-compression asymmetry, r-ratio, twinning, and texture evolution of a rolled magnesium alloy Mg-1.3Zn-0.4Ca-0.4Mn. Metall Mater Trans A2020; 51: 3858–3868.
5.
DongSYuQJiangYY, et al.Characteristic cyclic plastic deformation in ZK60 magnesium alloy. Int J Plasticity2017; 91: 25–47.
6.
WangMXuXWangH, et al.Evolution of dislocation and twin densities in a Mg alloy at quasi-static and high strain rates. Acta Mater2020; 201: 102–113.
7.
XieCHeJMZhuBW, et al.Transition of dynamic recrystallization mechanisms of as-cast AZ31 Mg alloys during hot compression. Int J Plasticity2018; 111: 211–233.
8.
WangXXMaoPLWangRF, et al.Role of twinning in the anisotropy and asymmetry of AZ31 magnesium alloy under high strain rate deformation. Mater Sci Eng A2020; 772: 138814.1–138814.12.
9.
NiewczasM. Lattice correspondence during twinning in hexagonal close-packed crystals. Acta Mater2010; 58: 5848–5857.
10.
LouC. Research of deformation twins and mechanical properties of AZ31 magnesium alloy subjected to dynamic plastic deformation [dissertation]. Chongqing (CN): Chongqing University, 2013.
11.
XuNMaoPZhouL, et al.Effect of pre-strain on extension twinning behavior in an extruded AZ31 Mg alloy observed by in-situ EBSD. Mater Charact2023; 200: 112–893.
12.
JinTZhouZQiuJ, et al.Investigation on the yield behavior of AZ91 magnesium alloy. J Alloys Compd2018; 738: 79–88.
13.
HouDZhuYLiQ, et al.Effect of twinning on the deformation behavior of AZ31 magnesium alloy. Mater Sci Eng A2019; 746: 314–321.
14.
HanGParkHKKimHK, et al.Local and global deformation behaviour in rolled pure magnesium sheets at room temperature under different strain rates. Mater Sci Eng A2019; 762: 138110.1–138110.10.
15.
ZhangWZhangHWangL, et al.Microstructure evolution and mechanical properties of AZ31 magnesium alloy sheets prepared by low-speed extrusion with different temperature. Crystals2020; 10: 644.
16.
FernándezAPérez PradoMTWeiY, et al.Continuum modeling of the response of a Mg alloy AZ31 rolled sheet during uniaxial deformation. Int J Plasticity2011; 27: 1739–1757.
17.
AsgariHSzpunarJAOdeshiAG, et al.Effect of grain size on high strain rate deformation of rolled Mg–4Y–3RE alloy in compression. Mater Sci Eng A2015; 633: 92–102.
18.
XiongYJiangY. Compressive deformation of rolled AZ80 magnesium alloy along different material orientations. J Mater Sci2020; 55: 4043–4053.
19.
GaoPZhuSQAnXH, et al.Effect of sample orientation and initial microstructures on the dynamic recrystallization of a Magnesium alloy. Mater Sci Eng A2017; 691: 150–154.
20.
ZhouLZhangJPLiYT, et al.Microstructure evolution of Mg-6Zn-0.6Zr alloy during high strain rate compression deformation. Mater Sci Technol2021; 37: 258–268.
21.
GuanDKWynneBGaoJH, et al.Basal slip mediated tension twin variant selection in magnesium WE43 alloy. Acta Mater2019; 170: 1–14.
22.
WangXXMaoPLLiuZ, et al.Nucleation and growth analysis of extension twins in AZ31 magnesium alloy during in-situ tension. J Alloys Compd2019; 817: 152967.
23.
WangRFMaoPLLiuY, et al.Influence of pre-twinning on high strain rate compressive behavior of AZ31 Mg-alloys. Mater Sci Eng A2019; 742: 309–317.
24.
XieDPanHLiM, et al.Role of Al addition in modifying microstructure and mechanical properties of Mg-1.0 wt% Ca based alloys. Mater Charact2020; 169: 110608.
25.
LuSHWuDChenRS, et al.Reasonable utilization of (10-12) twin for optimizing microstructure and improving mechanical property in a Mg-Gd-Y alloy. Mater Des2020; 191: 108600.
26.
KhosravaniAFullwoodDTAdamsBL, et al.Nucleation and propagation of twins in AZ31 magnesium alloy. Acta Mater2015; 100: 202–214.
27.
LiuGDXinRHShuXG, et al.The mechanism of twinning activation and variant selection in magnesium alloys dominated by slip deformation. J Alloys Compd2016; 687: 352–359.
28.
HouDWChenHCShiDF, et al.Study of twinning behaviors of rolled AZ31 magnesium alloy by interrupted in situ compressive tests. Mater Sci Eng A2016; 653: 108–114.
29.
YuJCSongBXiaDB, et al.Dynamic tensile properties and microstructural evolution of extruded EW75 magnesium alloy at high strain rates. J Magnesium Alloys2020; 8: 849–859.
30.
YangQSJiangBSongB, et al.The effects of orientation control via tension-compression on microstructural evolution and mechanical behavior of AZ31 Mg alloy sheet. J Magnesium Alloys2020; 28: 411–422.
31.
ZhangJJoshiSP. Phenomenological crystal plasticity modeling and detailed micromechanical investigations of pure magnesium. J Mech Phys Solids2012; 60: 945–972.
32.
ChenZYaghoobiMSundararaghavanV, et al.The effects of microstructure on deformation twinning in Mg WE43. Mater Sci Eng A2022; 859: 144189.
33.
RaeisiniaBAgnewSRAkhtarA, et al.Incorporation of solid solution alloying effects into polycrystal modeling of Mg alloys. Metall Mater Trans A2011; 42: 1418–1430.
34.
WuBLWanGDuXH, et al.The quasi-static mechanical properties of extruded binary Mg–Er alloys. Mater Sci Eng A2013; 573: 205–214.
35.
Reed-HillRERobertsonWD. Additional modes of deformation twinning in magnesium. Acta Metall Sinica1957; 5: 717–727.
36.
WangXX. Nucleation and growth mechanism of twins in magnesium alloy during in-situ tension [dissertation]. Shenyang (CN): Shenyang University of Technology, 2020.
37.
PanHCQinGWHuangYM, et al.Activating profuse pyramidal slips in magnesium alloys via raising strain rate to dynamic level. J Alloys Compd2016; 688: 149–152.
38.
WangFLAgnewRS. Dislocation transmutation by tension twinning in magnesium alloy AZ31. Int J Plasticity2016; 81: 63–86.
