Suitability of municipal solid waste in African cities for thermochemical waste-to-energy conversion: The case of Harare Metropolitan City,Zimbabwe

Abstract

The recovery of energy from municipal solid waste (MSW) has gained popularity in many industrialized countries, but its adoption in economically developing countries, especially in Africa, has been slow. While capital investments and technical requirements for waste-to-energy (WtE) systems are among the most important causes for this slow adoption, the unavailability of data on the thermochemical quality of MSW as a potential feedstock for energy recovery is also a limiting factor. In this paper, Harare, a typical African city, was selected as a case study. The evaluation was based on the analysis of the MSW’s composition, moisture as-discarded, thermochemical properties and energy content. The results show that the quality of the MSW is comparable to that in regions outside Africa where WtE has been a success. The combustible fraction exceeded 75 wt% making it ideal for thermal treatment without requiring supplementary fuel. With an MSW throughput of 421,757 tonnes year⁻¹ (11.1% of which is recycled), and a lower heating value of 10.1 MJ kg⁻¹, the energetic potential was estimated at 3.8 × 10⁶ GJ. MSW thermal treatment via conventional technologies can reduce the waste throughput to landfills by up to 40%, provide up to 112 GWh year⁻¹ of electrical energy, and increase the annual share of electrical energy produced from bio-fuels and wastes from 1.3% to at least 2.2%. These benefits make thermal MSW treatment a suitable option for waste disposal in African cities.

Keywords

Municipal solid waste (MSW)waste-to-energy MSW characterization waste management energy content African cities

Get full access to this article

View all access options for this article.

References

Aleluia

Ferrão

(2017) Assessing the costs of municipal solid waste treatment technologies in developing Asian countries. Waste Management 69: 592–608. https://doi.org/10.1016/j.wasman.2017.08.047.

Amsterdam

Thopil

(2017) Enablers towards establishing and growing South Africa’s waste to electricity industry. Waste Management 68: 774–785. https://doi.org/10.1016/j.wasman.2017.06.051.

A Situational Analysis of Solid Waste Management in Zimbabwe’s Urban Centres (2013) Harare, Zimbabwe: Institute of Environmental Studies, University of Zimbabwe, pp. 1–53.

ASTM E872-82 (2013a) Standard test method for volatile matter in the analysis of particulate wood fuels.

ASTM E1621-13 (2013b) Standard guide for elemental analysis by wavelength dispersive X-Ray fluorescence spectrometry.

ASTM E1756-08 (2015) Standard test method for determination of total solids in biomass.

ASTM D5231-92 (2016) Standard test method for determination of the composition of unprocessed municipal solid waste.

Basu

(2010) Biomass Gasification and Pyrolysis Practical Design and Theory. New York: Elsevier Ltd, p. 364.

Beyene

Werkneh

Ambaye

(2018) Current updates on waste to energy (WtE) technologies: A review. Renewable Energy Focus 24: 1–11. https://doi.org/10.1016/j.ref.2017.11.001.

10.

Brown

(2011) Thermochemical Processing of Biomass: Conversion into Fuels, Chemicals and Power. Wiley Series in Renewable Resources, Chichester: Wiley, p. 330.

11.

Cambridge Industries Energy (2017) Reppie waste-to-energy facility. Africa’s first waste-to-energy facility. Addis Ababa: Cambridge Industries Ltd. Available at: https://static1.squarespace.com/static/57c7f80620099eafefefe77a/t/58dbc65a579fb3ddac6737f1/1490798189352/Reppi+Brochure.pdf (accessed 11 December 2017).

12.

Chang

Y-H

Chen

Chang

N-B

(1998) Comparative evaluation of RDF and MSW incineration. Journal of Hazardous Materials 58: 33–45.

13.

Couth

Trois

(2012) Cost effective waste management through composting in Africa. Waste Management 32: 2518–25. https://doi.org/10.1016/j.wasman.2012.05.042.

14.

Dal Pozzo

Antonioni

Guglielmi

et al . (2016) Comparison of alternative flue gas dry treatment technologies in waste-to-energy processes. Waste Management 51: 81–90. https://doi.org/10.1016/j.wasman.2016.02.029.

15.

Eddine

Salah

(2012) Solid waste as renewable source of energy: Current and future possibility in Algeria. International Journal of Energy and Environmental Engineering 3: 1–12. https://doi.org/10.1186/2251–6832–3–17.

16.

Environmental Management Agency (EMA) (2016) Waste generation and management in Harare, Zimbabwe: Residential areas, commercial areas and schools. Unpublished internal report, Environmental Management Agency. Harare, Zimbabwe. Available at: http://www.ema.co.zw (accessed 20 January 2017).

17.

Environmental Protection Agency (EPA) (2016) Advancing sustainable materials management: 2014 fact sheet. Assessing trends in materials generation, recycling, composting, combusting with energy recovery and landfilling in the United States. November. Washington, DC: United States Environmental Protection Agency. Available at: https://www.epa.gov/sites/production/files/2016-11/documents/2014_smmfactsheet_508.pdf (accessed 8 October 2017).

18.

Hla

Roberts

(2015) Characterisation of chemical composition and energy content of green waste and municipal solid waste from Greater Brisbane, Australia. Waste Management 41: 12–19. https://doi.org/10.1016/j.wasman.2015.03.039.

19.

Hoornweg

Bhada-Tata

(2012) What a waste: A global review of solid waste management. Washington DC: World Bank. Available at: http://siteresources.worldbank.org/INTURBANDEVELOPMENT/Resources/336387-1334852610766/What_a_Waste2012_Final.pdf (accessed 20 November 2016).

20.

Hosokai

Matsuoka

Kuramoto

et al . (2016) Modification of Dulong’s formula to estimate heating value of gas, liquid and solid fuels. Fuel Processing Technology 152: 399–405. https://doi.org/10.1016/j.fuproc.2016.06.040.

21.

International Energy Agency (IEA) (2017) Non-member country reports: Zimbabwe. Report, International Energy Agency, Paris. Available at: https://www.iea.org/publications/freepublications/ (accessed 11 March 2018).

22.

Komilis

Kissas

Symeonidis

(2014) Effect of organic matter and moisture on the calorific value of solid wastes: An update of the Tanner diagram. Waste Management 34: 249–255. https://doi.org/10.1016/j.wasman.2013.09.023.

23.

Lombardi

Carnevale

Corti

(2015) A review of technologies and performances of thermal treatment systems for energy recovery from waste. Waste Management 37: 26–44. https://doi.org/10.1016/j.wasman.2014.11.010.

24.

J-W

Zhang

Hai

et al . (2017) Status and perspectives of municipal solid waste incineration in China: A comparison with developed regions. Waste Management 69: 170–186. https://doi.org/10.1016/j.wasman.2017.04.014.

25.

Makarichi

Jutidamrongphan

Techato

K-A

(2018) The evolution of waste-to-energy incineration: A review. Renewable and Sustainable Energy Reviews 91: 812–821. https://doi.org/10.1016/j.rser.2018.04.088.

26.

Malinauskaite

Jouhara

Czajczyńska

et al . (2017) Municipal solid waste management and waste-to-energy in the context of a circular economy and energy recycling in Europe. Energy 141: 2013–2044. https://doi.org/10.1016/j.energy.2017.11.128.

27.

Matsakas

Gao

Jansson

et al . (2017) Green conversion of municipal solid wastes into fuels and chemicals. Electronic Journal of Biotechnology 26: 69–83. https://doi.org/10.1016/j.ejbt.2017.01.004.

28.

Miezah

Obiri-Danso

Kádár

et al . (2015) Municipal solid waste characterization and quantification as a measure towards effective waste management in Ghana. Waste Management 46: 15–27. https://doi.org/10.1016/j.wasman.2015.09.009.

29.

Municipal Waste Characterization Procedures (1996) Ireland: Environmental Protection Agency, p. 1–27. Available at: https://www.epa.ie/pubs/reports/waste/wastecharacterisation/EPA_municipal_waste_characterisation.pdf (accessed 2 October 2016).

30.

Mutz

Hengevoss

Hugi

et al . (2017) Waste to energy options in municipal solid waste management for decision makers in developing and emerging countries. Bonn: Deutsche Gesellschaft für Internationale Zusammenarbeit. Available at: https://www.giz.de/en/downloads/GIZ_WasteToEnergy_Guidelines_2017.pdf (accessed 19 March 2018).

31.

Nordi

Bereche

Gallego

et al . (2017) Electricity production from municipal solid waste in Brazil. Waste Management & Research 35: 1–12. https://doi.org/10.1177/0734242X1770.

32.

Ogunjuyigbe

ASO

Ayodele

Alao

(2017) Electricity generation from municipal solid waste in some selected cities of Nigeria: An assessment of feasibility, potential and technologies. Renewable and Sustainable Energy Reviews 80: 149–162. https://doi.org/10.1016/j.rser.2017.05.177.

33.

Panepinto

Blengini

Genon

(2015) Economic and environmental comparison between two scenarios of waste management: MBT vs. thermal treatment. Resources, Conservation and Recycling 97: 16–23. https://doi.org/10.1016/j.resconrec.2015.02.002.

34.

Panepinto

Zanetti

(2018) Municipal solid waste incineration plant: A multi-step approach to the evaluation of an energy-recovery configuration. Waste Management 73: 332–41. https://doi.org/10.1016/j.wasman.2017.07.036.

35.

Rajaeifar

Ghanavati

Dashti

et al . (2017) Electricity generation and GHG emission reduction potentials through different municipal solid waste management technologies: A comparative review. Renewable and Sustainable Energy Reviews 79: 414–439. https://doi.org/10.1016/j.rser.2017.04.109.

36.

Rajcoomar

Ramjeawon

(2017) Life cycle assessment of municipal solid waste management scenarios on the small island of Mauritius. Waste Management & Research 35: 313–324. https://doi.org/10.1177/0734242X16679883.

37.

Rand

Haukohl

Marxen

(1999) Municipal solid waste incineration: A decision makers’ guide. Washington DC: World Bank. Available at: http://siteresources.worldbank.org/INTUSWM/Resources/463617-1202332338898/incineration-dmg.pdf (accessed 8 August 2016).

38.

Rizwan

Saif

Almansoori

et al . (2018) Optimal processing route for the utilization and conversion of municipal solid waste into energy and valuable products. Journal of Cleaner Production 174: 857–867. https://doi.org/10.1016/j.jclepro.2017.10.335.

39.

Roopnarain

Adeleke

(2017) Current status, hurdles and future prospects of biogas digestion technology in Africa. Renewable and Sustainable Energy Reviews 67: 1162–1179. https://doi.org/10.1016/j.rser.2016.09.087.

40.

Scarlat

Motola

Dallemand

et al . (2015) Evaluation of energy potential of municipal solid waste from African urban areas. Renewable and Sustainable Energy Reviews 50: 1269–1286. https://doi.org/10.1016/j.rser.2015.05.067.

41.

Schwarzböck

van Eygen

Rechberger

et al . (2016) Determining the amount of waste plastics in the feed of Austrian waste-to-energy facilities. Waste Management & Research 35: 207–216. https://doi.org/10.1177/0734242x16660372.

42.

Siddiqui

Zaidi

Manuja

et al . (2017) Development of models for prediction of the energy content of disposed municipal solid waste from an unsecure landfill. Waste Management & Research 35: 1129–1136. https://doi.org/10.1177/0734242X17725392.

43.

Snyman

Vorster

(2011) Towards zero waste: A case study in the city of Tshwane. Waste Management & Research 29: 512–520. https://doi.org/10.1177/0734242X10382947.

44.

Staley

(2013) Summary of waste conversion technologies. North Carolina: Environmental Research and Education Foundation. Available at: http://www.newmoa.org/events/docs/112_109/EREF_MSW_Conversion_Techs_Aug2013.pdf (accessed 11 October 2016).

45.

Sudibyo

Majid

Pradana

et al . (2017) Technological evaluation of municipal solid waste management system in Indonesia. Energy Procedia 105: 263–269. https://doi.org/10.1016/j.egypro.2017.03.312.

46.

Suthapanich

(2014) Characterization and assessment of municipal solid waste for energy recovery options in Phetchaburi, Thailand. BSc Thesis, Asian Institute of Technology, Thailand. Available at: http://faculty.ait.ac.th/visu/public/uploads/images/pdf/2014/wiratchapan.pdf.

47.

Tang

Lai

et al . (2013) Energy analysis and environmental impacts of a MSW oxy-fuel incineration power plant in China. Energy Policy 60: 132–141. https://doi.org/10.1016/j.enpol.2013.04.073.

48.

Vlaskin

(2018) Municipal solid waste as an alternative energy source. Proceedings of the Institution of Mechanical Engineers, Part A: Journal of Power and Energy 095765091876202. https://doi.org/10.1177/0957650918762023.

49.

Wilson

Rodic

Scheinberg

et al . (2012) Comparative analysis of solid waste management in 20 cities. Waste Management & Research 30: 237–254. https://doi.org/10.1177/0734242X12437569.

50.

World Energy Council (WEC) (2016) World energy resources. Waste to energy 2016. London: World Energy Council. Available at: https://www.worldenergy.org/wp-content/uploads/2017/03/WEResources_Waste_to_Energy_2016.pdf p. 76 (accessed 10 February 2018).

51.

Zhan

Chen

Lin

et al . (2016) Suppression of dioxins after the post-combustion zone of MSWIs. Waste Management 54: 153–161.

52.

Zhou

Long

Meng

et al . (2015) Classification of municipal solid waste components for thermal conversion in waste-to-energy research. Fuel 145: 151–157. https://doi.org/10.1016/j.fuel.2014.12.015.

53.

Zimbabwe National Statistics Report (2012) National Statistics Agency. Harare, Zimbabwe: Government of Zimbabwe. Available at: http://www.zimstat.co.zw/sites/default/files/img/publications/Population/National_Report.pdf (accessed 7 March 2017).

54.

Zimbabwe Integrated Solid Waste Management Plan (2014) Ministry of Environment, Water and Climate. Harare, Zimbabwe: Government of Zimbabwe, pp. 1–70.

Supplementary Material

Please find the following supplemental material available below.

For Open Access articles published under a Creative Commons License, all supplemental material carries the same license as the article it is associated with.

For non-Open Access articles published, all supplemental material carries a non-exclusive license, and permission requests for re-use of supplemental material or any part of supplemental material shall be sent directly to the copyright owner as specified in the copyright notice associated with the article.

0.00 MB

0.51 MB

1.05 MB