Biodegradable magnesium (Mg) alloys exhibit improved mechanical properties compared to degradable polymers while degrading in vivo circumventing the complications of permanent metals, obviating the need for surgical removal. This study investigated the safety and efficacy of Mg-Y-Zn-Zr-Ca (WZ42) alloy compared to non-degradable Ti6Al4V over a 14-week follow-up implanted as pins to fix a full osteotomy in rat femurs and as wires wrapped around the outside of the femurs as a cerclage. We used a fully load bearing model allowing implants to intentionally experience realistic loads without immobilization. To assess systemic toxicity, blood cell count and serum biochemical tests were performed. Livers and kidneys were harvested to observe any accumulation of alloying elements. Hard and soft tissues adjacent to the fracture site were also histologically examined. Degradation behavior and bone morphology were determined using micro-computed tomography scans. Corrosion occurred gradually, with degradation seen after two weeks of implantation with points of high stress observed near the fracture site ultimately resulting in WZ42 alloy pin fracture. At 14 weeks however, normal bone healing was observed in femurs fixed with the WZ42 alloy confirmed by the presence of osteoid, osteoblast activity, and new bone formation. Blood testing exhibited no significant changes arising from the WZ42 alloy compared to the two control groups. No recognizable differences in the morphology and more importantly, no accumulation of Mg, Zn, and Ca in the kidney and liver of rats were observed. These load bearing model results collectively taken, thus demonstrate the feasibility for use of the Mg-Y-Zn-Zr-Ca alloy for long bone fracture fixation applications.
ZhengYFGuXNWitteF.Biodegradable metals. Mater Sci Eng: R: Rep2014;
77: 1–34.
2.
WindhagenHRadtkeKWeizbauerAet al.
Biodegradable magnesium-based screw clinically equivalent to titanium screw in hallux valgus surgery: short term results of the first prospective, randomized, controlled clinical pilot study. Biomed Eng Online2013;
12: 62.
3.
LeeJ-WHanH-SHanK-Jet al.
Long-term clinical study and multiscale analysis of in vivo biodegradation mechanism of Mg alloy. Proc Natl Acad Sci USA2016;
113: 716–721.
4.
StaigerMPPietakAMHuadmaiJet al.
Magnesium and its alloys as orthopedic biomaterials: a review. Biomaterials2006;
27: 1728–1734.
5.
GrovesEWH.An experimental study of the operative treatment of fractures. Br J Surg1913;
1: 438–501.
6.
WitteFKaeseVHaferkampHet al.
In vivo corrosion of four magnesium alloys and the associated bone response. Biomaterials2005;
26: 3557–3563.
7.
ZreiqatHHowlettCRZannettinoAet al.
Mechanisms of magnesium-stimulated adhesion of osteoblastic cells to commonly used orthopaedic implants. J Biomed Mater Res2002;
62: 175–184.
8.
ZhangYFXuJKRuanYCet al.
Implant-derived magnesium induces local neuronal production of CGRP to improve bone-fracture healing in rats. Nat Med2016;
22: 1160–1169.
9.
WuLLFeyerabendFSchillingAFet al.
Effects of extracellular magnesium extract on the proliferation and differentiation of human osteoblasts and osteoclasts in coculture. Acta Biomater2015;
27: 294–304.
10.
JahnKSaitoHTaipaleenmakiHet al.
Intramedullary Mg2Ag nails augment callus formation during fracture healing in mice. Acta Biomater2016;
36: 350–360.
11.
ChayaAYoshizawaSVerdelisKet al.
In vivo study of magnesium plate and screw degradation and bone fracture healing. Acta Biomater2015;
18: 262–269.
12.
ChayaAYoshizawaSVerdelisKet al.
Fracture healing using degradable magnesium fixation plates and screws. J Oral Maxillofac Surg2015;
73: 295–305.
13.
ChouDTHongDSahaPet al.
In vitro and in vivo corrosion, cytocompatibility and mechanical properties of biodegradable Mg-Y-Ca-Zr alloys as implant materials. Acta Biomater2013;
9: 8518–8533.
14.
VelikokhatnyiOIKumtaPN.First-principles studies on alloying and simplified thermodynamic aqueous chemical stability of calcium-, zinc-, aluminum-, yttrium- and iron-doped magnesium alloys. Acta Biomater2010;
6: 1698–1704.
15.
WuARXiaCQ.Study of the microstructure and mechanical properties of Mg-rare earth alloys. Mater Des2007;
28: 1963–1967.
16.
GaoJCWuSQiaoLYet al.
Corrosion behavior of Mg and Mg-Zn alloys in simulated body fluid. Trans Nonferrous Met Soc China2008;
18: 588–592.
17.
LiuMSchmutzPUggowitzerPJet al.
The influence of yttrium (Y) on the corrosion of Mg-Y binary alloys. Corrosion Sci2010;
52: 3687–3701.
18.
BobeKWillboldEMorgenthalIet al.
In vitro and in vivo evaluation of biodegradable, open-porous scaffolds made of sintered magnesium W4 short fibres. Acta Biomater2013;
9: 8611–8623.
19.
SahaPViswanathanS.An analysis of the grain refinement of magnesium by zirconium. In: SillekensWHAgnewSRNeelamegghamNRet al. (eds) Magnesium technology 2011.
Cham:
Springer International Publishing, 2011, pp.175–180.
20.
SahaPViswanathanS.Engineering an efficient zirconium-based grain refiner for magnesium alloys. Inter Metalcast2010;
4: 70–71.
21.
Saha P, Lolies K, Viswanathan S, et al. A systematic study of the grain refinement of magnesium by zirconium. Magnesium Technology 2010; 425–430.
22.
Saha P and Viswanathan S. Grain refinement of magnesium by zirconium: characterization and analysis. American Foundry Society Proceedings 2011; 119: 469–480.
23.
WitteFHortNVogtCet al.
Degradable biomaterials based on magnesium corrosion. Curr Opin Solid State Mat Sci2008;
12: 63–72.
24.
SongGSt JohnD.The effect of zirconium grain refinement on the corrosion behaviour of magnesium-rare earth alloy MEZ. J Light Metals2002;
2: 1–16.
25.
ZhangSXZhangXNZhaoCLet al.
Research on an Mg-Zn alloy as a degradable biomaterial. Acta Biomater2010;
6: 626–640.
26.
HanziACGerberISchinhammerMet al.
On the in vitro and in vivo degradation performance and biological response of new biodegradable Mg-Y-Zn alloys. Acta Biomater2010;
6: 1824–1833.
27.
HanziACSologubenkoASUggowitzerPJ.Design strategy for new biodegradable Mg-Y-Zn alloys for medical applications. IJMR2009;
100: 1127–1136.
28.
BaoLZhangZQLeQCet al.
Corrosion behavior and mechanism of Mg-Y-Zn-Zr alloys with various Y/Zn mole ratios. J Alloy Compd2017;
712: 15–23.
29.
FanJQiuXNiuXDet al.
Microstructure, mechanical properties, in vitro degradation and cytotoxicity evaluations of Mg-1.5Y-1.2Zn-0.44Zr alloys for biodegradable metallic implants. Mater Sci Eng C-Mater Biol Appl2013;
33: 2345–2352.
30.
IlichJZKerstetterJE.Nutrition in bone health revisited: a story beyond calcium. J Am Coll Nutr2000;
19: 715–737.
31.
DryndaAHasselTHoehnRet al.
Development and biocompatibility of a novel corrodible fluoride-coated magnesium-calcium alloy with improved degradation kinetics and adequate mechanical properties for cardiovascular applications. J Biomed Mater Res Part A2010;
93A: 763–775.
32.
LiZJGuXNLouSQet al.
The development of binary Mg-Ca alloys for use as biodegradable materials within bone. Biomaterials2008;
29: 1329–1344.
33.
BotteMJDavisJLRoseBAet al.Complications of smooth pin fixation of fractures and dislocations in the hand and wrist. Clin Orthopaed Relat Res1992; 194–201.
34.
HargreavesDGDrewSJEckersleyR.Kirschner wire pin tract infection rates: a randomized controlled trial between percutaneous and buried wires. J Hand Surg (Edinburgh, Scotland) 2004;
29: 374–376.
35.
RafiqueAGhaniSSadiqMet al.
Kirschner wire pin tract infection rates between percutaneous and buried wires in treating metacarpal and phalangeal fractures. J Coll Phys Surg Pak2006;
16: 518–520.
36.
HochwaldNLLevineRTornettaP3rd.The risks of Kirschner wire placement in the distal radius: a comparison of techniques. J Hand Surg Am1997;
22: 580–584.
37.
SharmaHTaylorGRClarkeNMP.A review of K-wire related complications in the emergency management of paediatric upper extremity trauma. Ann R Coll Surg Engl2007;
89: 252–258.
38.
HsuLPSchwartzEGKalainovDMet al.
Complications of K-wire fixation in procedures involving the hand and wrist. J Hand Surg Am2011;
36: 610–616.
39.
QianMStJohnDHFrostMT.Zirconium alloying and grain refinement of magnesium alloys. In Magnesium Technology 2003 as held at the 2003 TMS Annual Meeting2003; (pp.
209–214).
40.
ChouD-T.Fundamental study of the development and evaluation of biodegradable Mg-Y-Ca-Zr based alloys as novel implant materials. PhD Thesis, University of Pittsburgh, Pittsburgh, PA, 2016.
41.
GuXNXieXHLiNet al.
In vitro and in vivo studies on a Mg-Sr binary alloy system developed as a new kind of biodegradable metal. Acta Biomater2012;
8: 2360–2374.
Material ASfTa. ASTM G31-72 standard practice for laboratory immersion corrosion testing of metals. Annual book of ASTM standards.
Philadelphia, PA:
ASTM, 2004.
44.
AnYHGruberHE.Introduction to experimental bone and cartilage histology. In: YHAnKLMartin (eds) Handbook of histology methods for bone and cartilage.
Totowa, NJ:
Humana Press, 2003, pp.3–31.
45.
YamazakiMMajeskaRJYoshiokaHet al.
Spatial and temporal expression of fibril-forming minor collagen genes (types V and XI) during fracture healing. J Orthop Res1997;
15: 757–764.
46.
BostromMPGLaneJMBerberianWSet al.
Immunolocalization and expression of bone morphogenetic proteins 2 and 4 in fracture healing. J Orthop Res1995;
13: 357–367.
47.
EinhornTAMajeskaRJRushEBet al.
The expression of cytokine activity by fracture callus. J Bone Miner Res1995;
10: 1272–1281.
48.
IwakiAJingushiSOdaYet al.
Localization and quantification of proliferating cells during rat fracture repair: detection of proliferating cell nuclear antigen by immunohistochemistry. J Bone Miner Res1997;
12: 96–102.
49.
HausmanMRSchafflerMBMajeskaRJ.Prevention of fracture healing in rats by an inhibitor of angiogenesis. Bone2001;
29: 560–564.
50.
RyhänenJKallioinenMSerloWet al. Bone healing and mineralization of femoral osteotomy fixed with intramedullary NiTi rod. SMST-2000: proceedings of the international conference on shape memory and superelastic technologies. Materials Park, OH, USA: ASM International, 2001, pp.339–345.
51.
IglesiasCBodelonOGMontoyaRet al.Fracture bone healing and biodegradation of AZ31 implant in rats. Biomed Mater2015;
10: 025008.
52.
LammGAuerJWeberTet al.
Postoperative white blood cell count predicts atrial fibrillation after cardiac surgery. J Cardiothorac Vasc Anesth2006;
20: 51–56.
53.
MushaharyDSravanthiRLiYet al.
Zirconium, calcium, and strontium contents in magnesium based biodegradable alloys modulate the efficiency of implant-induced osseointegration. Int J Nanomed2013;
8: 2887–2902.
54.
HouLLiZPanYet al.
In vitro and in vivo studies on biodegradable magnesium alloy. Progr Nat Sci: Mater Int2014;
24: 466–471.
55.
ZhangEXuLYuGet al.
In vivo evaluation of biodegradable magnesium alloy bone implant in the first 6 months implantation. J Biomed Mater Res2009;
90: 882–893.
56.
HartwigA.Role of magnesium in genomic stability. Mutation Res/Fundamental Mol Mech Mutagenesis2001;
475: 113–121.
57.
LiHFXieXHZhaoKet al.
In vitro and in vivo studies on biodegradable CaMgZnSrYb high-entropy bulk metallic glass. Acta Biomater2013;
9: 8561–8573.
58.
HabibovicPBarraletJE.Bioinorganics and biomaterials: bone repair. Acta Biomater2011;
7: 3013–3026.
59.
HoppeAGuldalNSBoccacciniAR.A review of the biological response to ionic dissolution products from bioactive glasses and glass-ceramics. Biomaterials2011;
32: 2757–2774.
60.
RimKTKooKHParkJS.Toxicological evaluations of rare earths and their health impacts to workers: a literature review. Safety Health Work2013;
4: 12–26.
61.
HiranoSSuzukiKT.Exposure, metabolism, and toxicity of rare earths and related compounds. Environ Health Perspect1996;
104: 85–95.
62.
AngrisaniNReifenrathJZimmermannFet al.
Biocompatibility and degradation of LAE442-based magnesium alloys after implantation of up to 3.5 years in a rabbit model. Acta Biomater2016;
44: 355–365.
63.
AmerstorferFFischerauerSFFischerLet al.
Long-term in vivo degradation behavior and near-implant distribution of resorbed elements for magnesium alloys WZ21 and ZX50. Acta Biomater2016;
42: 440–450.
64.
TuryanskayaARauwolfMGrunewaldTAet al.
mu XRF elemental mapping of bioresorbable magnesium-based implants in bone. Materials2016;
9: 11.
65.
ChoudharyLSingh RamanRK.Magnesium alloys as body implants: fracture mechanism under dynamic and static loadings in a physiological environment. Acta Biomater2012;
8: 916–923.
66.
KannanMBRamanRKS.In vitro degradation and mechanical integrity of calcium-containing magnesium alloys in modified-simulated body fluid. Biomaterials2008;
29: 2306–2314.
67.
ChoudharyLSingh RamanRKHofstetterJet al.
In-vitro characterization of stress corrosion cracking of aluminium-free magnesium alloys for temporary bio-implant applications. Mater Sci Eng C Mater Biol Appl2014;
42: 629–636.
68.
LevesqueJHermawanHDubeDet al.
Design of a pseudo-physiological test bench specific to the development of biodegradable metallic biomaterials. Acta Biomater2008;
4: 284–295.
69.
ChenYZhangSLiJet al.
Dynamic degradation behavior of MgZn alloy in circulating m-SBF. Mater Lett2010;
64: 1996–1999.
70.
HollingerJWongME.The integrated processes of hard tissue regeneration with special emphasis on fracture healing. Oral Surg, Oral Med, Oral Pathol, Oral Radiol Endodontics1996;
82: 594–606.
71.
ShawBA.Corrosion resistance of magnesium alloys. ASM Handbook – corrosion: fundamentals, testing, and protection.
Materials Park:
ASM International, 2003, pp.692–696.
72.
JaninRNinaANinaEet al.
Degrading magnesium screws ZEK100: biomechanical testing, degradation analysis and soft-tissue biocompatibility in a rabbit model. Biomed Mater2013;
8: 045012.
73.
WitteFFischerJNellesenJet al.
In vitro and in vivo corrosion measurements of magnesium alloys. Biomaterials2006;
27: 1013–1018.
74.
BuckwalterJAETBolanderMECruessRLet al. Healing of the musculoskeletal tissues. In: RockwoodCA (ed.) Rockwood and green’s fractures in adults.
Philadelphia:
Lippincott-Raven, 1996, pp.261–304.
75.
WaizyHDiekmannJWeizbauerAet al.
In vivo study of a biodegradable orthopedic screw (MgYREZr-alloy) in a rabbit model for up to 12 months. J Biomater Appl2014;
28: 667–675.
76.
KuhlmannJBartschIWillboldEet al.
Fast escape of hydrogen from gas cavities around corroding magnesium implants. Acta Biomater2013;
9: 8714–8721.
77.
SfeirCHoLDollBAet al.Fracture repair. In: LiebermanJRFriedlaenderGE (eds) Bone regeneration and repair: biology and clinical applications.
Totowa, NJ:
Humana Press, 2005, pp.21–44.
YoshizawaSBrownABarchowskyAet al.Magnesium ion stimulation of bone marrow stromal cells enhances osteogenic activity simulating the effect of magnesium alloy degradation. Acta Biomater 2014; 10: 2834–2842.
80.
WitteFUlrichHRudertMet al.
Biodegradable magnesium scaffolds: part I: appropriate inflammatory response. J Biomed Mater Res2007;
81: 748–756.
81.
SeitzJ-MLucasAKirschnerM.Magnesium-based compression screws: a novelty in the clinical use of implants. JOM2016;
68: 1177–1182.
