A phenomenological combustion analysis of a dual-fuel natural-gas diesel engine

Abstract

Energy security concerns and an abundant supply of natural gas in the USA provide the impetus for engine designers to consider alternative gaseous fuels in the existing engines. The dual-fuel natural-gas diesel engine concept is attractive because of the minimal design changes, the ability to preserve a high compression ratio of the baseline diesel, and the lack of range anxiety. However, the increased complexity of a dual-fuel engine poses challenges, including the knock limit at a high load, the combustion instability at a low load, and the transient response of an engine with directly injected diesel fuel and port fuel injection of compressed natural gas upstream of the intake manifold. Predictive simulations of the complete engine system are an invaluable tool for investigations of these conditions and development of dual-fuel control strategies. This paper presents the development of a phenomenological combustion model of a heavy-duty dual-fuel engine, aided by insights from experimental data. Heat release analysis is carried out first, using the cylinder pressure data acquired with both diesel-only and dual-fuel (diesel and natural gas) combustion over a wide operating range. A diesel injection timing correlation based on the injector solenoid valve pulse widths is developed, enabling the diesel fuel start of injection to be detected without extra sensors on the fuel injection cam. The experimental heat release trends are obtained with a hybrid triple-Wiebe function for both diesel-only operation and dual-fuel operation. The ignition delay period of dual-fuel operation is examined and estimated with a predictive correlation using the concept of a pseudo-diesel equivalence ratio. A four-stage combustion mechanism is discussed, and it is shown that a triple-Wiebe function has the ability to represent all stages of dual-fuel combustion. This creates a critical building block for modeling a heavy-duty dual-fuel turbocharged engine system.

Keywords

Dual fuel natural gas diesel combustion triple-Wiebe function

Get full access to this article

View all access options for this article.

References

Final rulemaking to establish greenhouse gas emissions standards and fuel efficiency standards for medium- and heavy-duty engines and vehicles. Report EPA-420-R-11-901, US Environmental Protection Agency, Office of Transportation and Air Quality, and US Department of Transportation, National Highway Traffic Safety Administration, Washington, DC, USA, 2011.

Annual energy outlook 2015. Report DOE/EIA 0383(2015), US Department of Energy, US Energy Information Administration, Office of Integrated and International Energy Analysis, Washington, DC, USA, 2015.

Short-term energy outlook (STEO). Report, US Department of Energy, US Energy Information Administration, Office of Integrated and International Energy Analysis, Washington, DC, USA, July 2015.

Korakianitis

Namasivayam

Crookes

Natural-gas fueled spark-ignition (SI) and compression-ignition (CI) engine performance and emissions. Prog Energy Combust Sci 2011; 37: 89–112.

Krishnan

Biruduganti

. Performance and heat release analysis of a pilot-ignited natural gas engine. Int J Engine Res 2002; 3: 171–184.

Liu

Karim

An examination of the ignition delay period in gas-fueled diesel engines. Trans ASME, J Engng Gas Turbines Power 1998; 120: 225–231.

Karim

Klat

Moore

Knock in dual-fuel engines. Proc IMechE 1966; 181(1): 453–466.

Karim

Khan

Examination of effective rates of combustion heat release in a dual-fuel engine. J Mech Engng Sci 1968; 10(1): 13–23.

Karim

GA.

The dual fuel engine. Berlin: Springer, 1987, pp. 83–104.

10.

Al-Himyary

Karim

A correlation for the burning velocity of methane–air mixtures at high pressures and temperatures. Trans ASME, J Engng Gas Turbines Power 1987; 109: 439–442.

11.

Karim

Liu

A predictive model for knock in dual fuel engines. SAE paper 922366, 1992.

12.

Liu

Karim

Simulation of combustion processes in gas-fuelled diesel engines. Proc IMechE Part A: J Power and Energy 1997; 211: 159–169.

13.

Climate change 2014 synthesis report. Report, Intergovernmental Panel on Climate Change, Geneva, Switzerland, 2014.

14.

Krishnan

Srinivasan

Singh

. Strategies for reduced NO_x emissions in pilot-ignited natural gas engines. Trans ASME, J Engng Gas Turbines Power 2004; 126: 665–671.

15.

Srinivasan

Krishnan

Singh

. The advanced injection low pilot ignited natural gas engine: a combustion analysis. Trans ASME, J Engng Gas Turbines Power 2006; 128: 213–218.

16.

Krishnan

Srinivasan

Midkiff

KC.

Ignition in pilot-ignited natural gas low temperature combustion: multi-zone modeling and experimental results. In: ASME 2009 Internal Combustion Engine Division spring technical conference, Milwaukee, Wisconsin, USA, 3–6 May 2009, paper ICES2009-76145, pp. 625–634. New York: ASME.

17.

Krishnan

Srinivasan

Multi-zone modelling of partially premixed low-temperature combustion in pilot-ignited natural-gas engines. Proc IMechE Part D: J Automobile Engineering 2010; 224(12): 1597–1622.

18.

Srinivasan

Krishnan

Midkiff

Improving low load combustion, stability, and emissions in pilot-ignited natural gas engines. Proc IMechE Part D: J Automobile Engineering 2006; 220(2): 229–239.

19.

Vibe

. Semi-empirical expression for combustion rate in engines. In: Conference on piston engines, Moscow, USSR, 1956, pp. 185–191. Moscow: USSR Academy of Sciences.

20.

Watson

Pilley

Marzouk

A combustion correlation for diesel engine simulation. SAE paper 800029, 1980.

21.

Miyamoto

Chikahisa

Murayama

Sawyer

Description and analysis of diesel engine rate of combustion and performance using Wiebe’s functions. SAE paper 850107, 1985.

22.

Karim

GA.

Combustion in gas fueled compression: ignition engines of the dual fuel type. Trans ASME, J Engng Gas Turbines Power 2003; 125: 827–836.

23.

Abd Alla

Soliman

Badr

Abd Rabbo

MFl

. Using of quasi-two zone combustion model to predict the performance of a dual fuel engine. SAE paper 2000-01-2936, 2000.

24.

Singh

Liang

Kong

S-C

Reitz

RD.

Development of a flame propagation model for dual-fuel partially premixed compression ignition engines. Int J Engine Res 2006; 7: 65–75.

25.

Cordiner

Rocco

Scarcelli

. Experiments and multi-dimensional simulation of dual-fuel diesel/natural gas engines. SAE paper 2007-24-0124, 2007.

26.

Singh

Kong

S-C

Reitz

. Modeling and experiments of dual-fuel engine combustion and emissions. SAE paper 2004-01-0092, 2004.

27.

Zhang

Kong

S-C

Reitz

RD.

Modeling and simulation of a dual fuel (diesel/natural gas) engine with multidimensional CFD. SAE paper 2003-01-0755, 2003.

28.

Mbarawa

Milton

Casey

RT.

Experiments and modelling of natural gas combustion ignited by a pilot diesel fuel spray. Int J Thermal Sci 2001; 40: 927–936.

29.

Zhang

Frankel

SH.

A numerical study of natural gas combustion in a lean burn engine. Fuel 1998; 77: 1339–1347.

30.

Heywood

JB.

Internal combustion engine fundamentals. New York: McGraw-Hill, 1988.

31.

Woschni

A universally applicable equation for the instantaneous heat transfer coefficient in the internal combustion engine. SAE paper 670931, 1967.

32.

Assanis

Filipi

Fiveland

Syrimis

A predictive ignition delay correlation under steady-state and transient operation of a direct-injection diesel engine. Trans ASME, J Engng Gas Turbines Power 1999; 125: 450–457.

33.

Ghojel

Review of the development and applications of the Wiebe function: a tribute to the contribution of Ivan Wiebe to engine research. Int J Engine Res 2010; 11: 297–312.

34.

Anderson

Singh

. Development of a phenomenological dual-fuel natural gas diesel engine simulation and its use for analysis of transient operations. SAE paper 2014-01-2546, 2014.

35.

Assanis

Sekar

Marr

Karvounis

Heat release analysis of oxygen-enriched diesel Combustion. Trans ASME, J Engng Gas Turbines Power 1993; 115: 761–768.