Internal leakage analysis and experiment in hydraulic control system of steam turbine inlet valve

Abstract

In this paper, the transformation of steam turbine regulating system from mechanical hydraulic regulation to electro-hydraulic regulation is realized. And the internal leakage mechanism of the hydraulic control switch valve and the electro-hydraulic proportional valve in the system is analyzed. With the use of hydraulic simulation software AMESim, the mathematical model of the electro-hydraulic control system after transforming is established. The parameters of the hydraulic control switch valve and the electro-hydraulic proportional valve in the hydraulic control system of steam turbine inlet valve are studied under different internal leakage locations and different leakage degree, such as piston regulating time, steady position of piston, oil pressure and leakage flow flux. The fault characteristic table of internal leakage is obtained. An experimental platform for simulating internal leakage is built. The experimental curves of several physical quantities under different internal leakage conditions are obtained. The experimental results prove that the internal leakage has a great impact on the performance of the electro-hydraulic control system. The results of internal leakage experiment are consistent with those of internal leakage simulation.

Keywords

Internal leakage analysis hydraulic control system fault diagnosis steam turbine AMESim

Get full access to this article

View all access options for this article.

References

Chen

XW.

Internal leakage detection for inlet guide vane system at gas turbine compressor with ensemble empirical mode decomposition. Measurement 2019; 134: 781–787.

Liu

Min

, et al. Erosion behavior and influence of solid particles in hydraulic spool valve without notches. Eng Failure Anal 2020; 1: 262–284.

Pavlos

Dimitrios

Theodore

, et al. Operational fault diagnosis in industrial hydraulic systems through modeling the internal leakage of its components. Amer J Appl Sci 2013; 10: 1648–1659.

Ren

Masoumeh

Song

, et al. Position control of an electrohydrostatic actuator with tolerance to internal leakage. IEEE Trans Control Syst Technol 2016; 24: 1–9.

Yao

Yang

DW.

Internal leakage fault detection and tolerant control of single-rod hydraulic actuators. Math Prob Eng 2014; 2014: 1–14.

Amin

Nariman

A wavelet-based approach for external leakage detection and isolation from internal leakage in valve-controlled hydraulic actuators. IEEE Trans Ind Electron 2011; 58: 4374–4384.

Amin

Nariman

A wavelet-based approach to internal seal damage diagnosis in hydraulic actuators. IEEE Trans Ind Electron 2010; 57: 1755–1763.

Amin

Nariman

A wavelet-based approach for diagnosis of internal leakage in hydraulic actuators using on-line measurements. Int J Fluid Power 2010; 1: 61–69.

Amin

Nariman

Internal leakage detection in hydraulic actuators using empirical mode decomposition and Hilbert spectrum. IEEE Instrum Meas 2012; 61: 368–378.

10.

Siavash

Ali

Mehdi

, et al. Leakage fault detection in electro-hydraulic servo systems using a nonlinear representation learning approach. ISA Trans 2018; 73: 154–164.

11.

Guo

Zeng

, et al. Modeling and experimental study for online measurement of hydraulic cylinder micro leakage based on convolutional neural network. Sensors 2019; 19: 2159–2119.

12.

Tang

Hua

, et al. Internal leakage fault diagnosis of hydraulic cylinder using PCA and BP network. J Central South Univ 2011; 42: 3709–3714.

13.

Yao

JY.

Artificial neural network–based internal leakage fault detection for hydraulic actuators: an experimental investigation. Proc IMechE, Part I: J Systems and Control Engineering 2017; 232: 1–14.

14.

Huang

Tao

, et al. Featured temporal segmentation method and AdaBoost-BP detector for internal leakage evaluation of a hydraulic cylinder. Measurement 2018; 130: 279–289.

15.

Zhao

Zhang

Zhou

, et al. Experimental study of hydraulic cylinder leakage and fault feature extraction based on wavelet packet analysis. Comput Fluids 2015; 106: 33–40.

16.

Jin

Shan

, et al. Fault diagnosis of hydraulic seal wear and internal leakage using wavelets and wavelet neural network. IEEE Trans Instrum Meas 2018; 99: 1–9.

17.

Yao

Tang

Rui

, et al. A time–frequency analysis based internal leakage detection method for hydraulic actuators. Adv Mech Eng 2017; 9: 1–8.

18.

Vishal

Douglas

Mark

Derivative free filtering in hydraulic systems for fault identification. Control Eng Pract 2011; 19: 649–657.

19.

WK.

Standard deviation based acoustic emission signal analysis for detecting valve internal leakage. Sensor Actuators A Phys 2018; 283: 340–347.

20.

Huang

Tao

, et al. Internal leakage identification of hydraulic cylinder based on intrinsic mode functions with random forest. Proc IMechE, Part C: J Mechanical Engineering Science 2019; 233: 5532–5544.

Supplementary Material

Please find the following supplemental material available below.

For Open Access articles published under a Creative Commons License, all supplemental material carries the same license as the article it is associated with.

For non-Open Access articles published, all supplemental material carries a non-exclusive license, and permission requests for re-use of supplemental material or any part of supplemental material shall be sent directly to the copyright owner as specified in the copyright notice associated with the article.

0.00 MB

0.07 MB

0.13 MB

0.24 MB

0.12 MB

0.21 MB