An evaluation of occupant dynamics during moderate-to-high speed side impacts

Abstract

The present study examined trends in occupant dynamics during side impact testing in vehicle models over the past decade. “Moderate-to-high” speed side impacts (delta-V ≥15 km/h) were analyzed. The Insurance Institute for Highway Safety (IIHS) side impact crash data was examined (N = 126). The test procedure involved a moving deformable barrier (MDB) impacting the sides of stationary vehicles at 50.0 km/h. Instrumented 5th-percentile female SID IIs dummies were positioned in the driver and left rear passenger seats. Occupant head, neck, shoulder, torso, spine, and pelvis/femur responses (times histories, peaks, and time-to-peak values) were evaluated and compared to injury assessment reference values (IARVs). The effects of delta-V, vehicle model year, vehicle body type, and occupant seating position on dynamic responses were examined. The vehicle lateral delta-Vs ranged from 15.9 to 34.5 km/h. The MY2018-2020 demonstrated lower peak dynamics than MY2010-2013, for the driver head acceleration (53.7 ± 11.3g vs 46.4 ± 11.6g), shoulder lateral forces (1.7 ± 0.7 kN vs 1.5 ± 0.2 kN), average rib deflection (29.8 ± 8.3 mm vs 28.4 ± 6.2 mm), spine accelerations at T4 (51.4 ± 23.4g vs 39.6 ± 5.9g) and T12 (56.3 ± 18.5g vs 45.2 ± 9.6g), iliac forces (1.9 ± 1.0 kN vs 1.2 ± 0.9 kN), and acetabular forces (1.9 ± 0.8 kN vs 1.3 ± 0.5 kN). The driver indicated statistically higher dynamic responses than the left rear passenger. Higher wheelbase vehicles generally showed lower occupant loading than the smaller vehicles. In conclusion, a reduction in occupant loading and risks for injury was observed in vehicle models over the past decade. This provides further insight into injury mechanisms, occupant dynamics simulations, and seat/restraint design.

Keywords

Occupant dynamics loading SID-IIs side impact high-speed IIHS

Get full access to this article

View all access options for this article.

References

Kumaresan

Sances

Carlin

, et al. Biomechanics of side impact injuries: evaluation of seat belt restraint system, occupant kinematics and injury potential. In: Proceedings of the 28th IEEE EMBS annual international conference, New York City, USA, 30 August–30 September 2006, pp.87–90.

Pintar

Yoganandan

Stemper

, et al. Comparison of PMHS, WorldSID, and THOR-NT responses in simulated far side impact. STAPP Car Crash J 2007; 51: 313–360.

Suderman

Scher

Ching

. Likelihood of lumbar spine injuries for far-side occupants in low to moderate speed lateral impacts. SAE technical paper 2014-01-0494, 2014.

Augenstein

Bowen

Perdeck

, et al. Injury patterns in near-side collisions. SAE technical paper 2000-01-0634, 2000.

Digges

Dalmotas

. Injuries to restrained occupants in far-side crashes. In: Proceedings of the 17th international technical conference on the enhanced safety of vehicles, Amsterdam, Netherlands, 4–7 June 2001.

Imler

Heller

Corrigan

, et al. The effect of side impact collision delta-V, restraint status, and occupant position on injury outcome. SAE technical paper 2010-01-1158, 2010.

Stadter

Grabowski

Burke

, et al. Injury and side impact air bag deployment in near and far sided motor vehicle crashes, United States, 2000–2005. J Trauma 2008; 65(6): 1333–1339.

Lam

Ivarsson

. Likelihood of spinal disc herniations in occupants involved in real world side impacts. SAE technical paper 2020-01-0526, 2020.

Furbish

Welcher

Brink

, et al. Occupant kinematics and loading in low speed lateral impacts. SAE Int J Adv Curr Pract Mobil 2019; 1(4): 1470–1490.

10.

Mkandawire

Mazzucco

Vijayakumar

, et al. Head kinematics and upper neck loading during simulated low-speed lateral impact collisions. In: FISITA world automotive congress, Yokohama, Japan, 22–27 June 2006.

11.

Kloppenborg

Amenson

Wernik

, et al. Low-speed go-Kart crash tests and a comparison to activities of daily living. ASCE-ASME J Risk Uncertain Eng Syst 2018; 4: 041010.

12.

Bussone

Moore

Locey

, et al. Frontal, lateral, and free-operation impacts of amusement bumper cars: vehicle kinematics and occupant kinematics. SAE technical paper 2018-01-0543, 2018.

13.

Skiera

Crosby

Bare

, et al. Passenger vehicle dynamic response and characterization of side structure during low- to moderate-speed side impacts. SAE Int J Adv Curr Pract Mobil 2019; 1(3): 918–950.

14.

Viano

Parenteau

. Occupant-to-occupant contact injury in motor vehicle crashes. Traffic Inj Prev 2017; 18(7): 744–747.

15.

Chudnovsky

Stocks-Smith

Padmanaban

, et al. Belted driver injury in near-side and far-side impacts, past and present. SAE technical paper 2016-01-1530, 2016.

16.

Youn

Park

Kim

, et al. Comparison of injury severity between near and far side occupants on the side collisions. In: 25th international technical conference on the enhanced safety of vehicles (ESV) National Highway Traffic Safety Administration, Detroit, Michigan, United States, 5–8 June 2017.

17.

George

Davis

Sharpe

, et al. Evaluation of occupant kinematics during low- to moderate-speed side impacts. SAE technical paper 2020-01-1222, 2020.

18.

Toney-Bolger

Sherman

Isaacs

, et al. An evaluation of near- and far-side occupant responses to low- to moderate-speed side impacts. SAE technical paper 2020-01-1218, 2020.

19.

Federal Motor Vehicle Safety Standard (FMVSS) No. 214. Side impact protection. 49 C.F.R. § 571.214, 2010.

20.

U.S. Department of Transportation National Highway Traffic Safety Administration Office of Crashworthiness Standards. Laboratory test procedures for the new car assessment program side impact rigid pole test, 2012.

21.

Insurance Institute for Highway Safety (IIHS). Crashworthiness evaluation side impact crash test protocol (version X), 2017.

22.

Insurance Institute for Highway Safety (IIHS). Dummy seating procedure for rear outboard positions (version I), 2012.

23.

Insurance Institute for Highway Safety (IIHS). Guidelines for using the UMTRI ATD positioning procedure for ATD and seat positioning (version V), 2004.

24.

Society of Automotive Engineers (SAE). Surface vehicle recommended practice: (R) instrumentation for impact test—part 1—electronic instrumentation. SAE J211-1, 1995.

25.

Society of Automotive Engineers (SAE). Surface vehicle information report: sign convention for crash testing. SAE J1733, 1994.

26.

Scanlon

Isaacs

Garman

. Head and neck loading conditions over a decade of IIHS rear impact seat testing. SAE 2019-01-1227, 2019.

27.

U.S. Department of Transportation National Highway Traffic Safety Administration. How vehicle age and model year relate to driver injury severity in fatal crashes. Traffic safety facts, DOT HS 811 825, 2013.

28.

U.S. Department of Transportation National Highway Traffic Safety Administration. Relationship of vehicle weight to fatality and injury risk in model year 1985–93 passenger cars and light trucks. NHTSA summary report number DOT HS 808 569, 2013.

29.

Fugger

Randles

Wobrock

, et al. Human occupant kinematics in low speed side impacts 1010 total citations on dimensions. SAE technical paper 2002-01-0020, 2002.

30.

Parenteau

Shah

Steffan

, et al. Volunteer and dummy head kinematics in low-speed lateral sled tests. Traffic Inj Prev 2002; 3(3): 233–240.

31.

Parenteau

. Far-side occupant kinematics in low speed lateral sled. Traffic Inj Prev 2006; 7(2): 164–170.

32.

Shibata

Roberts

Sprague

, et al. The kinematic analysis of occupant excursions and accelerations during staged low speed far-side lateral vehicle-to-vehicle impacts. SAE technical paper 2019-01-1030, 2019.

33.

Atarod

. Occupant kinematics during moderate-to-high speed side impacts: an analysis of IIHS crash data over the past decade. SAE technical paper 2020-01-5165, 2020.

34.

Kuppa

Eppinger

McKoy

, et al. Development of side impact thoracic injury criteria and their application to the modified ES-2 dummy with rib extensions (ES-2re). Stapp Car Crash J 2003; 47: 189–210.

35.

Yoganandan

Pintar

Stempera

, et al. Biomechanics of side impact: injury criteria, aging occupants, and airbag technology. J Biomech 2007; 40(2): 227–243.

36.

Viano

Parenteau

Prasad

, et al. Occupant responses in high-speed rear crashes: analysis of government-sponsored tests. SAE technical paper 2008-01-0188, 2008.

37.

Atarod

. Occupant dynamics during moderate-to-high speed rear-end collisions. SAE technical paper 2020-01-0516, 2020.

38.

Ikeda

Mae

. Comparison of thorax responses between WorldSID-5th and SID-IIs in lateral and oblique impacts. 25ESV-000364, 2017.