Horizontal axis wind turbine dynamic stall predictions based on wind speed and direction variability

Abstract

The onset of dynamic stall in horizontal axis wind turbines (HAWTs) is related to the rapid increase in the angle of attack caused by sudden changes in wind speed and direction. In order to relate the changes in wind speed and direction with the variations in the blade-section angle of attack, an analytical model is proposed to determine the regions of the blade affected by dynamic stall. The so-called threshold radius has been identified and defined as the percentage of the blade length from the horizontal axis wind turbines hub beyond which the probability of dynamic stall occurrence falls to zero. High quality wind data were acquired to determine the average wind conditions that serve as the model inputs. It is shown that the rate of change of wind speed, due to gusts or the average turbulence, can cause large regions of dynamic stall on the wind turbine blade. Other parameters, such as the yaw misalignment and the rate of change of yaw angle are shown to be the cause of asymmetrical distribution of threshold radius with azimuth and also serve to increase the affected regions. Finally it is shown that the type of airfoil used in the turbine blade also has a significant effect on the threshold radius due to the different limiting reduced frequencies.

Keywords

Horizontal axis wind turbine dynamic stall reduced frequency wind turbine yaw response gust response turbulence intensity

Get full access to this article

View all access options for this article.

References

Herbert

GMJ

Iniyan

Sreevalsan

. A review of wind energy technologies. Renew Sustain Energy Rev 2007; 11: 1117–1145.

Maldonado

Farnsworth

Gressick

. Active control of flow separation and structural vibrations of wind turbine blades. Wind Energy 2010; 13: 221–237.

Carr

Chandrasekhara

. Compressibility effects on dynamic stall. Prog Aerosp Sci 1996; 32: 523–573.

Carr LW, McAlister KW and McCroskey WJ. Analysis of the development of dynamic stall based on oscillating airfoil experiments. Report TN D-8382, National Aeronautics and Space Administration, 1977.

Butterfield

Simms

Scott

. Dynamic stall on wind turbine blades, Golden, CO: National Renewable Energy Laboratory, 1991.

Shipley

Miller

Robinson

. Dynamic stall occurrence on a horizontal axis wind turbine blade, Golden, CO: National Renewable Energy Laboratory, 1995.

Larsen

Nielsen

SRK

Krenk

. Dynamic stall model for wind turbine airfoils. J Fluid Struct 2007; 23: 959–982.

Burton T. Wind energy: handbook. New York: John Wiley & Sons, Ltd., 2001.

Sun

Sheikh

. Dynamic stall suppression on an oscillating airfoil by steady and unsteady tangential blowing. Aerosp Sci Technol 1999; 3: 355–366.

10.

Shipley

Miller

Robinson

. Techniques for the determination of local dynamic pressure and angle of attack on a horizontal axis wind turbine, Golden, CO: National Renewable Energy Laboratory, Boulder, CO: Colorado University, 1995.

11.

Melbourne

. Criteria for environmental wind conditions. J Wind Eng Ind Aerodyn 1978; 3: 241–249.

12.

Beljaars ACM. The measurement of gustiness at routine wind stations: a review. Instruments and Observing Methods Report No 31, World Meteorological Organization, Geneva, 1987.

13.

McCroskey WJ, McAlister KW, Carr LW, et al. An experimental study of dynamic stall on advanced airfoil sections. Volume 1: Summary of the experiment. NASA Technical Memorandum, 1982.

14.

Schreck

Robinson

Hand

. Blade dynamic stall vortex kinematics for a horizontal axis wind turbine in yawed conditions. J Sol Energy Eng 2001; 123: 272–272.

15.

Leishman

. Dynamic stall experiments on the NACA 23012 aerofoil. Exp Fluids 1990; 9: 49–58.

16.

McCroskey

Carr

McAlister

. Dynamic stall experiments on oscillating airfoils. AIAA J 1976; 14: 57–63.

17.

Ramsay

Hoffmann

Gregorek

. Effects of grit roughness and pitch oscillations on the S809 airfoil, NREL/TP-442-7817. Golden, CO: National Renewable Energy Laboratory, 1995.

18.

Hansen

. Yaw dynamics of horizontal axis wind turbines, Golden, CO: National Renewable Energy Laboratory, Salt Lake City, UT: Utah University, 1992.

19.

Coleman RP, Feingold AM and Stempin CW. Evaluation of the induced-velocity field of an idealized helicoptor rotor. National Aeronautics and Space Admistration, Langley Research Center, Hampton, VA, 1945.

20.

Swift A Jr. Effects of yawed flow on wind turbine rotors. PhD Thesis, Washington University, USA, 1981.

21.

Dolan

DSL

Lehn

. Simulation model of wind turbine 3p torque oscillations due to wind shear and tower shadow. IEEE Trans Energy Convers 2006; 21(3): 717–724.

22.

Wang

Coton

. A high resolution tower shadow model for downwind wind turbines. J Wind Eng Ind Aerodyn 2001; 89: 873–892.

23.

Somers

. Design and experimental results for the S809 airfoil, Golden, CO: National Renewable Energy Laboratory, 1997.

24.

Hutchins

Marusic

. Evidence of very long meandering features in the logarithmic region of turbulent boundary layers. J Fluid Mech 2007; 579: 1–1.

25.

Hutchins NC, Marusic K, Monty I, et al. Towards reconciling the large-scale structure of turbulent boundary layers in the atmosphere and laboratory. Boundary-Layer Meteorol 2012.

26.

ESDU. Characteristics of wind speed in the lower layers of the atmosphere near the ground: strong winds (neutral atmosphere). Engineering Sciences Data Unit, 1972.

27.

Holmes

. Wind loading of structures, London: Spon Press, 2001.

28.

Zoumakis

. The dependence of the power-law exponent on surface roughness and stability in a neutrally and stably stratified surface boundary layer. Atmosfera 2009; 6: 79–83.

29.

Deacon

. Gust variation with height up to 150 m. Quart J Roy Meteorol Soc 1955; 81: 562–573.

30.

Panofsky H. A survey of current throught on wind properties relevant for diffusion in the lowest 100 m. In: Symposium on atmospheric turbine diffusion, Sandia Laboratories, Albuquerque, NM, 1967, pp.47–58.

31.

DS472. Code of practice for loads and safety of wind turbine constructions. Copenhagen: The Danish Society of Engineers and the Federation of Engineers, 1992.

32.

Harris RI. The nature of the wind. In: Proceedings CIRIA seminar on the modern design of wind-sensitive structures. London: Construction Industry Resrearch and Information Association, 1970.