Simulation of near surge instabilities onset in a turbocharger compressor

Abstract

This study focuses on numerical simulations of a small automotive turbocharger compressor stage. Two medium speed characteristics were reproduced from nominal operating points to surge and were compared with experimental measurements. The aim of this study is to analyze the flow unsteadiness occurring near the surge line. The complete geometry of the impeller is meshed; hence, no spatio-temporal hypothesis is done during simulations. The main flow patterns are investigated to identify structures that might be responsible of surge inception. Results show that both impeller and diffuser are affected by stall. Blade channels are affected by a complete shroud recirculation extending from upstream of the impeller inlet to the diffuser inlet. Three radial recirculation zones are detected on the vaneless diffuser walls, strongly influenced by the two-pike asymmetric pressure field induced by the volute tongue. Its influence is observed at the inlet of the compressor, increasing the inter-blade flow unsteadiness.

Keywords

Centrifugal compressors turbochargers vaneless diffuser stall surge

Get full access to this article

View all access options for this article.

References

Japikse

Baines

. Introduction to turbomachinery, Wilder, VT, USA: Concept ETI Inc, 1994.

Tartousi H, Kulisa P, Leboeuf F, et al. Numerical investigation of a turbocharger centrifugal compressor: volute influence on the performance of the compressor. In: 9th European conference on turbomachinery, Istanbul, Turkey, 21–25 March 2011, vol. 2, pp.925–934.

Girsberger

Rohne

. Investigation of the flow phenomena in the inlet of an unshrouded centrifugal compressor impeller operating at part load. In: Fourth International Conference on Turbocharging and Turbochargers 22–24 May 1990, Institution of Mechanical Engineers, Birdcage Walk, London, pp. 197–205.

Barrand JP, Caignaert G, Canavelis R, et al. Experimental determination of the reverse flow onset in a centrifugal impeller. In: Proceedings of the first international pump symposium, Houston, TX, 22–24 May 1984, pp.63–71.

Nili-Ahmadabadi M, Hajilouy-Benisi A, Durali M, et al. Experimental & numerical investigation of a centrifugal compressor and numerical study of the area ratio and tip clearance effects on the performance characteristic. In: Proceedings of ASME turbo expo, Berlin, Germany, 9–13 June 2008, GT2008-50969.

Chen H, Guo S, Zhu XC, et al. Numerical simulations of onset of volute stall inside a centrifugal compressor. In: ASME Turbo Expo 2008, Power for Land, Sea, and Air, Volume 6, Berlin, Germany, June 9–13, 2008, pp.1447–1457.

Mizuki

Oosawa

. Unsteady flow within centrifugal compressor channels under rotating stall and surge. J Turbomach 1992; 114: 312–320.

Frigne P and Van den Braembussche R. Distinction between different types of impeller and diffuser rotating stall in a centrifugal compressor with vaneless diffuser. In: ASME, International Gas Turbine conference exhibit, Phoenix, AZ, 27–31 March 1983.

Jansen

. Rotating stall in a radial vaneless diffuser. J Basic Eng 1964; 86(4): 750–758.

10.

Japikse

. Centrifugal compressor design and performance, Wilder, VT, USA: Concept ETI Inc, 1996.

11.

Fink

Cumpsty

Greitzer

. Surge dynamics in a free-spool centrifugal compressor system. J Turbomach 1992; 14: 321–332.

12.

Greitzer

. Surge and stall in axial flow compressors—part I: theorical compression system model. J Eng Power 1976; 98(2): 190–198.

13.

Greitzer

. Surge and stall in axial flow compressors—part II: experimental results and comparison with theory. J Eng Power 1976; 98(2): 199–211.

14.

Galindo

Serrano

Climent

. Experiments and modelling of surge in small centrifugal compressor for automotive engines. Exp Therm Fluid Sci 2008; 32: 818–826.

15.

Otosan OBF and Mendonça F. Automotive turbocharger compressor CFD and extension towards incorporating installation effects. In: Proceedings of ASME turbo expo, Vancouver, Canada, 6–10 June 2011, GT2011-46796.

16.

Cambier L and Veuillot J. Status of the elsA CFD software for flow simulation and multidisciplinary applications. In: 46th AIAA aerospace science meeting exhibit, Reno, Nevada, 7–10 January 2008, p.664.

17.

Trébinjac

Bulot

Buffaz

. Analysis of the flow in a transonic centrifugal compressor stage from choke to surge. J Power Energy 2011; 225: 919–929.

18.

Mohtar

Chesse

Chalet

. Describing uncertainties encountered during laboratory turbocharger compressor tests. Exp Tech 2011; 36: 53–61.