Downstream flat plate as the flow-induced vibration enhancer for energy harvesting

Abstract

The prospect of harvesting energy from flow-induced vibration using an elastic square cylinder with a detached flat plate is experimentally investigated. The feasibility of flow-induced vibration to supply an adequate base excitation for micro-scale electrical power generation is assessed through a series of wind tunnel tests. The current test model of a single square cylinder is verified through a comparable pattern of vibration amplitude response with previous experimental study and two-dimensional numerical simulations based on the unsteady Reynolds averaged Navier–Stokes (URANS). In addition, a downstream flat plate is included in the wake of the square cylinder to study the effects of wake interference upon flow-induced vibration. A downstream flat plate is introduced as the passive vibration control to enhance the magnitude of flow-induced vibration and simultaneously increases the prospect of harvesting energy from the airflow. The study is conducted by varying the gap separation between the square cylinder and flat plate for 0.1≤ G/D ≤3. The highest peak amplitude is observed for the gap G/D = 1.2 with y_rms/D = 0.46 at U_R = 17, which is expected to harvest ten times more energy than the single square cylinder. The high amplitude vibration response is sustained within a relatively broader range of lock-in synchronization. Meanwhile, for G/D = 2 the vibration is suppressed, which leads to a lower magnitude of harvested energy. Contrarily, the amplitude response pattern for G/D = 3 is in agreement with the single square cylinder. Hence, the flat plate has no significance to the wake interference of the square cylinder when the gap separation is beyond 3D.

Keywords

Square cylinder flat plate aeroelasticity flow-induced vibration energy harvesting

Get full access to this article

View all access options for this article.

References

Abdelkefi

(2016) Aeroelastic energy harvesting: A review. International Journal of Engineering Science 100: 112–135.

Abdelkefi

Hajj

Nayfeh

(2012) Power harvesting from transverse galloping of square cylinder. Nonlinear Dynamics 70(2): 1355–1363.

Ali

MSM

Doolan

Wheatley

(2012) Low Reynolds number flow over a square cylinder with a detached flat plate. International Journal of Heat and Fluid Flow 36: 133–141.

Amandolse

Hmon

(2010) Vortex-induced vibration of a square cylinder in wind tunnel. Comptes Rendus Mécanique 338(1): 12–17.

Assi GR and Bearman PW (2009) VIV and WIV suppression with parallel control plates on a pair of circular cylinders in tandem. In: ASME 2009 28th international conference on ocean, offshore and arctic engineering, Honolulu, Hawaii, USA, 31 May–5 June 2009, pp.263–268. USA: American Society of Mechanical Engineers.

Bearman

(1984) Vortex shedding from oscillating bluff bodies. Annual Review of Fluid Mechanics 16(1): 195–222.

Beeby

Torah

Tudor

et al. (2007) A micro electromagnetic generator for vibration energy harvesting. Journal of Micromechanics and Microengineering 17(7): 1257.

Beeby

Tudor

White

(2006) Energy harvesting vibration sources for microsystems applications. Measurement Science and Technology 17(12): R175.

Bernitsas

Raghavan

Ben-Simon

et al. (2008) VIVACE (vortex induced vibration aquatic clean energy): A new concept in generation of clean and renewable energy from fluid flow. Journal of Offshore Mechanics and Arctic Engineering 130(4): 041101.

10.

Billah

Scanlan

(1991) Resonance, Tacoma narrows bridge failure, and undergraduate physics textbooks. American Journal of Physics 59(2): 118–124.

11.

Blevins R (1995) Vortex–structure interaction. In: Fluid Vortices, Prague, Czech Republic, 26–30 July 2009, pp.533–574. USA: Springer.

12.

Blevins RD (1990) Flow-induced Vibration. New York, NY, USA: Van Nostrand Reinhold Co., Inc.

13.

Chang

C-CJ

Kumar

Bernitsas

(2011) VIV and galloping of single circular cylinder with surface roughness at 3.0 × 10⁴ ≤ Re ≤ 1.2 × 10⁵. Ocean Engineering 38(16): 1713–1732.

14.

Ding

Zhang

et al. (2015) Flow induced motion and energy harvesting of bluff bodies with different cross sections. Energy Conversion and Management 91: 416–426.

15.

Durfee W and Sun Z (2009) Fluid Power System Dynamics. USA: Center for Compact and Efficient Fluid Power.

16.

Garg

Anderson

(2003) Structural damping and vibration control via smart sensors and actuators. Journal of Vibration and Control 9(12): 1421–1452.

17.

Gerrard

(1966) The mechanics of the formation region of vortices behind bluff bodies. Journal of Fluid Mechanics 25(2): 401–413.

18.

Howey

Bansal

Holmes

(2011) Design and performance of a centimetre-scale shrouded wind turbine for energy harvesting. Smart Materials and Structures 20(8): 085021.

19.

Jasak

Tukovic

(2006) Automatic mesh motion for the unstructured finite volume method. Transactions of FAMENA 30(2): 1–20.

20.

Jayatunga

HGKG

Tan

Leontini

(2015) A study on the energy transfer of a square prism under fluid-elastic galloping. Journal of Fluids and Structures 50: 384–397.

21.

Jung

H-J

Lee

S-W

(2011) The experimental validation of a new energy harvesting system based on the wake galloping phenomenon. Smart Materials and Structures 20(5): 055022.

22.

Kato

Koide

Takahashi

et al. (2012) VIVs of a circular cylinder with a downstream strip-plate in cruciform arrangement. Journal of Fluids and Structures 30: 97–114.

23.

Kausar

Reza

Saleh

et al. (2014) Energizing wireless sensor networks by energy harvesting systems: Scopes, challenges and approaches. Renewable and Sustainable Energy Reviews 38: 973–989.

24.

Kawabata Y, Haginoya T, Koide M, et al. (2009) Interference effect of wake body on the cross flow oscillation of a square cylinder in uniform flow. In: ASME 2009 pressure vessels and piping conference, Prague, Czech Republic, 26–30 July 2009, pp.229–238. USA: American Society of Mechanical Engineers.

25.

Kawabata

Takahashi

Haginoya

et al. (2013) Interference effect of downstream strip-plate on the crossflow vibration of a square cylinder. Journal of Fluid Science and Technology 8(3): 348–363.

26.

Khalak

Williamson

(1999) Motions, forces and mode transitions in vortex-induced vibrations at low mass-damping. Journal of fluids and Structures 13(7): 813–851.

27.

Koide

Sekizaki

Yamada

et al. (2013) Prospect of micro power generation utilizing VIV in small stream based on verification experiments of power generation in water tunnel. Journal of Fluid Science and Technology 8(3): 294–308.

28.

Yuan

Lipson

(2011) Ambient wind energy harvesting using cross-flow fluttering. Journal of Applied Physics 109(2): 026104.

29.

Menter

(1994) Two-equation eddy-viscosity turbulence models for engineering applications. AIAA Journal 32(8): 1598–1605.

30.

Mitcheson

Yeatman

Rao

et al. (2008) Energy harvesting from human and machine motion for wireless electronic devices. Proceedings of the IEEE 96(9): 1457–1486.

31.

Modi

Seto

(1998) Passive control of flow-induced oscillations using rectangular nutation dampers. Journal of Vibration and Control 4(4): 381–404.

32.

Ozono

(1999) Flow control of vortex shedding by a short splitter plate asymmetrically arranged downstream of a cylinder. Physics of Fluids 11: 2928–2934.

33.

Parkinson

(1989) Phenomena and modelling of flow-induced vibrations of bluff bodies. Progress in Aerospace Sciences 26(2): 169–224.

34.

Parkinson

Brooks

NPH

(1961) On the aeroelastic instability of bluff cylinders. Journal of Applied Mechanics 28(2): 252–258.

35.

Saaed

Nikolakopoulos

Jonasson

J-E

et al. (2015) A state-of-the-art review of structural control systems. Journal of Vibration and Control 21(5): 919–937.

36.

Sarpkaya

(1979) Vortex-induced oscillations: A selective review. Journal of Applied Mechanics 46(2): 241–258.

37.

Weinstein

Cacan

et al. (2012) Vortex shedding induced energy harvesting from piezoelectric materials in heating, ventilation and air conditioning flows. Smart Materials and Structures 21(4): 045003.

38.

Williamson

Govardhan

(2004) Vortex-induced vibrations. Annual Review of Fluid Mechanics 36: 413–455.

39.

Zhou

Cheng

Hung

(2005) Suppression of fluid force on a square cylinder by flow control. Journal of Fluids and Structures 21(2): 151–167.