Lighting and Energetic Characteristics of Transparent Insulating Materials: Experimental Data and Calculation

Abstract

This paper reports the study of thermal and optical properties of innovative transparent insulating materials (TIM) for glazing systems: silica aerogel (pane and granular) and capillary geometric media. Twenty-one samples were assembled with several kinds of glasses in various combinations with TIM. Transmission and reflection coefficients versus wavelength were measured and the results were elaborated in compliance with UNI EN 410/2000. The better performance was given by the monolithic aerogel both for light transmittance (0.58 in interspace between two 4mm float glasses) and thermal insulation (U = 0.63 W • m^{— 2} • K^—1). The solar factor was 0.70. The performance of the innovative glazing systems was compared with data related to windows normally used in Italy and in EU countries, in order to comply with the limits of the local normative standard required for thermal transmittance. The results showed a very promising behaviour of TIMs, in fact a 60% reduction in heat losses with respect to a double glazing with a low-e layer was achieved, with only a 27% reduction in light transmittance. For the granular systems, a U-value little higher than 1 W • m^—2 • K^—1 with the same total thickness was obtained, even if the light reduction was about 66%.

Keywords

Aerogel Capillary TIM Light transmittance Solar factor Thermal transmittance Transparent insulation materials

Get full access to this article

View all access options for this article.

References

United Nations Framework Convention on Climate Change: Kyoto Protocol to the United Nations Framework Convention on Climate Change, 1997 .

Oral GK , Yener AK , Bayazit NT : Building envelope design with the objective to ensure thermal, visual and acoustic comfort conditions: Build Environ 2004;3:281-287.

AbuBakr Bahaj S. , James PAB , Jentsch MF : Potential of emerging glazing technologies for highly glazed buildings in hot arid climates: Energy Build 2008;5:720-731.

Kaushika ND , Sumathy K. : Solar transparent insulation materials: A review: Renew Sustain Energy Rev 2003;7:317-351.

Kistler SS : Coherent expanded aerogels and jellies: Nature 1931;127:741-741.

Tajiri K. , Igarashi K. : The effect of the preparation conditions on the optical properties of transparent silica aerogels: Sol Energy Mater Sol Cells 1998;4:189-195.

Anderson AM , Wattley CW , Carroll MK : Silica aerogels prepared via rapid supercritical extraction: Effect of process variables on aerogel properties: J Non-Cryst Solids 2009;2:101-108.

Reim M. , Reichenauer G. , Körner W. , Manara J. , Arduini-Schuster M. , Korder S. , Beck A. , Fricke J. : Silica-aerogel granulate - structural, optical and thermal properties : J Non-Cryst Solids 2004;350:358-363.

Akimov YK : Fields of application of aerogels (Review): Instrum Exp Tech 2003;3:287-299.

10.

Ackerman WC , Vlachos M. , Rouanet S. , Fruendt J. : Use of surface treated aerogels derived from various silica precursors in translucent insulation panels: J Non-Cryst Solids: 2001;285:264-271.

11.

Schultz JM , Jensen KI , Kristiansen FH : Super insulating aerogel glazing: Sol Energy Mater Sol Cells 2005;89:275-285.

12.

Reim M. , Beck A. , Körner W. , Petricevic R. , Glora M. , Weth M. , Schliermann T. , Schmidt CH , Pötter FJ , Fricke J. : Highly insulating aerogel glazing for solar energy usage: Sol Energy 2002;1:21-29.

13.

Duer K. , Svendsen S. : Monolithic silica aerogel in superinsulating glazings: Sol Energy 1998;63:259-267.

14.

Jensen KI , Schultz JM , Kristiansen FH : Development of windows based on highly insulating aerogel glazings : J Non-Cryst Solids 2004;350:351-357.

15.

Rigaccia A. , Einarsrudb M. , Nilsenb E. , Pirardc R. , Ehrburger-Dolled F. , Chevalier B. : Improvement of the silica aerogel strengthening process for scaling-up monolithic tile production: J Non-Cryst Solids 2004;350:196- 201.

16.

Schultz JM , Jensen KI : Evacuated aerogel glazings: Vacuum 2008;82:723-729.

17.

Reim M. , Korner W. , Manara J. , Korder S. , Arduini-Schuster M. , Ebert HP , Fricke J. : Silica aerogel granulate material for thermal insulation and daylighting : Sol Energy 2005;2:131- 139.

18.

Spagnol S. , Lartigue B. , Trombe A. , Gibiat V. : Modeling of thermal conduction in granular silica aerogels: J Sol-Gel Sci Technol 2008;1-2:40-46.

19.

Hollands KGY , Iynkaran K. : Analytical model for the thermal conductance of compound honeycomb transparent insulation, with experimental validation : Sol Energy 1993;3:223-227.

20.

Airglass AB : Sweden. Available at: http://www.airglass.se/ (accessed June 8, 2004).

21.

Cabot Corporation: USA. Available at: http://w1.cabot-corp.com/index.jsp (accessed December 19, 2007 ).

22.

Okalux GmbH , Germany. Available at: http://www.okalux.com/ (accessed December 20, 2007).

23.

Saint-Gobain Glass , Italy. Available at: http://www.saint-gobain.it (accessed January 25, 2008).

24.

Gugliermetti F. , Buratti C. , Ortica S. : Indagini spettrofotometriche per la valutazione dell’invecchiamento di vetrate artistiche: in Proceedings of the Convegno Nazionale AIDI ‘‘Luce come innovazione’’ 2001; 62-64 (in Italian).

25.

Buratti C. : Transparent insulating materials: experimental data and buildings energy saving evaluation: in Proceedings of ENERGY & ENVIRONMENT 2003, First International Conference on Sustainable Energy, Planning & technology in Relationship to the Environment, Halkidiki, Greece, 2003.

26.

UNI EN 410: Vetro per Edilizia- Determinazione delle Caratteristiche Luminose e Solari delle Vetrate, 2000 (in Italian).

27.

Buratti C. , Moretti E. : Misura delle proprietà energetiche e luminose di sistemi vetrati con aerogel granulare: in Proceedings of the Convegno annuale ATI, Salerno, 2007 (in Italian).

28.

UNI EN 673: Vetro per edilizia- Determinazione della trasmittanza termica (valore U) - Metodo di calcolo, 2005 (in Italian).

29.

UNI EN ISO 10077-1: Prestazione termica di finestre, porte e chiusure oscuranti - Calcolo della trasmittanza termica - Parte 1: Generalità, 2007 (in italian).

30.

AGC Flat Glass Europe: Chaussée de la Hulpe 166, 1170 Belgium, Brussels, 2009.

31.

Directive 2002/91/EC of the European Parliament and of the Council of 16 December 2002 on the energy performance of buildings, OJ LI, January 4, 2003, pp. 65-73.

32.

Italian Legislative Decree 311: Disposizioni correttive ed integrative al decreto legislativo 19 agosto 2005, n. 192, recante attuazione della direttiva 2002/91/CE, relativa al rendimento energetico nell’edilizia , 2006 (in Italian).