Potential of ozone addition on dethrottling of a gasoline/ethanol blend-fueled direct injection spark ignition engine in part load

Several efforts are required to improve engine efficiency and decrease global carbon dioxide (CO₂) emissions and local pollutant products. In countries like Brazil, with a four-decade long experience with ethanol, the use of fossil fuels, although widespread, is being put under intense scrutiny. Governmental programs like ROTA 2030 stimulate engine research and development focused on environment-friendly fuels such as bioethanol-gasoline blends. Brazilian gasoline has about a quarter of ethanol, reducing the carbon footprint while maintaining suitable energy density. Regardless of the fuel, the load control method in part load operation of spark ignition engine causes a considerable penalty in fuel conversion efficiency. For these reasons, ozone addition was tested as an ignition enhancer that would allow higher de-throttling to reduce part-load pumping losses. The residual gas was used to dilute the mixture due to the possibility of keeping the three-way catalyst working properly with the stoichiometric mixture. An experimental investigation on efficiency, emissions and combustion related parameters was carried out in a downsized 1.0 l turbocharged direct-injected engine. Experimental tests were performed at 3 bar of indicated mean effective pressure (IMEP), 1500 rpm and stoichiometric air-fuel ratio. Spark timing (ST) was adjusted to achieve maximum indicated efficiency and the fuel used was Brazilian gasoline. Different ozone concentrations were used as a mixture with the intake air to overcome unstable engine operation by enhancing ignition. The results showed that it is possible to increase the gas exchange efficiency with ozone addition by promoting de-throttling operation with residual gases. Furthermore, the ozone addition exhibits the potential to promote autoignition of the end gas with spark assistance, even with a low compression ratio and residual gas fraction higher than 30%. However, the combustion efficiency is impaired by the higher residual gas fraction in some operation points that leave room for improvements.