Direct-write piezoelectric coating transducers in combination with discrete ceramic transducer and laser pulse excitation for ultrasonic impact damage detection on composite plates

Abstract

In this work, direct-write piezoelectric transducers (DWTs) were made by spraying piezoelectric poly(vinylidene fluoride-co-trifluoroethylene) coating with comb-shaped electrodes on carbon fibre reinforced polymer (CFRP) plates for drop weight impact damage detection. Their ability and performance were investigated and compared to discrete piezoelectric lead zirconate titanate (PZT) ceramic transducers that were adhesively bonded on the same CFRP plate. Guided wave signals were acquired with different combinations of actuator-sensor involving DWT, PZT and laser ultrasonic excitation, in pitch-catch configuration. DWTs allowed consistency and simplified signal interpretation due to an effective mode selection (A₀ or S₀ mode) with wavelengths of 10 and 12 mm. PZTs generated stronger but much more complex signals and mode selection with a larger wavelength (20 mm). The configuration with PZT as actuator and DWT as receiver showed the highest signal amplitude changes of A₀ or S₀ mode, allowing efficient detection of damage introduced by a 31 J impact. Further ultrasonic B- and C-scans revealed a 27 mm long crack on the plate’s backside developed in addition to internal cracks and delaminations of about 34 mm in length. For realizing contactless ultrasound excitation, a neodymium-doped yttrium aluminium garnet laser (wavelength of 1064 nm, 5.4 ns pulses) was used to replace the surface-mounted brittle PZT. The combination of the broadband laser excitation with the DWTs as sensors achieved more reliable damage detection than equivalent PZTs, attributed to DWT’s effective single mode selection. In addition to reduced weight, the polymeric coated DWTs allow large area implementation (scaling up), even on curved surfaces due to their flexibility and conformability, in contrast to adhesively bonded discrete transducers.

Keywords

Piezoelectric coatings ultrasonic transducers composite materials direct write Lamb waves structural health monitoring impact damage detection laser ultrasonic

Get full access to this article

View all access options for this article.

References

Soutis

. Carbon fiber reinforced plastics in aircraft construction. Mater Sci Eng A 2005; 412: 171–176.

Giurgiutiu

. Structural health monitoring of aerospace composites. Waltham, MA, USA: Academic, 2016. DOI: 10.1016/C2012-0-07213-4.

Davies

GAO

Olsson

. Impact on composite structures. Aeronaut J 2004; 108: 541–563.

Shi

Soutis

. Modelling low velocity impact induced damage in composite laminates. Mech Adv Mater Mod Process 2017; 3: 14.

Balageas

Fritzen

Güemes

. Structural health monitoring. London, UK: ISTE Ltd, 2006. DOI: 10.1002/9780470612071.

. Identification of damage using lamb waves: from fundamentals to applications. Berlin, Germany: Springer Science & Business Media, 2009. DOI: 10.1007/978-1-84882-784-4.

Staszewski

Mahzan

Traynor

. Health monitoring of aerospace composite structures–active and passive approach. Composites Sci Tech 2009; 69: 1678–1685.

Sohn

Liu

. Non-contact laser ultrasonics for SHM in aerospace structures. In: Structural health monitoring (SHM) in aerospace structures. Duxford, UK: Elsevier Inc., 2016, pp. 325–352.

Kapoor

Blackshire

Soni

. Damage detection in z-fiber reinforced, co-cured composite pi-joint using pitch-catch ultrasonic analysis and scanning laser vibrometry. Tech Sci Press 2010; 3: 221–238.

10.

Kessler

Spearing

Soutis

. Damage detection in composite materials using lamb wave methods. Smart Mater Struct 2002; 11: 269–278.

11.

Muller

Soutis

Gresil

. Image reconstruction and characterisation of defects in a carbon fibre/epoxy composite monitored with guided waves. Smart Mater Struct 2019; 28: 065001.

12.

Philibert

Soutis

Gresil

, et al. Damage detection in a composite t-joint using guided lamb waves. Aerospace 2018; 5: 40.

13.

Ihn

Chang

. Pitch-catch active sensing methods in structural health monitoring for aircraft structures. Struct Health Monit 2008; 7: 5–19.

14.

Qiu

Liu

Qing

, et al. A quantitative multidamage monitoring method for large-scale complex composite. Struct Health Monit 2013; 12: 183–196.

15.

Wang

Tang

. Damage detection using piezoelectric transducers and the lamb wave approach: I. System analysis. Smart Mater Struct 2008; 17: 025033.

16.

Giurgiutiu

. Tuned lamb wave excitation and detection with piezoelectric wafer active sensors for structural health monitoring. J Intell Mater Syst Struct 2005; 16: 291–305.

17.

Lin

Giurgiutiu

. Modeling and testing of PZT and PVDF piezoelectric wafer active sensors. Smart Mater Struct 2006; 15: 1085–1093.

18.

Bellan

Bulletti

Capineri

, et al. A new design and manufacturing process for embedded Lamb waves interdigital transducers based on piezopolymer film. Sensors Actuators A: Phys 2005; 123–124: 379–387.

19.

Rajic

Rosalie

van der Velden

, et al. A novel high density piezoelectric sensing capability for in situ modal decomposition of acoustic emissions. In: Proceedings of 9th EWSHM, Manchester, United Kingdom, 10–13 July 2018.

20.

Tuloup

Harizi

Aboura

, et al. Integration of piezoelectric transducers (PZT and PVDF) within polymer-matrix composites for structural health monitoring applications: new success and challenges. Int J Smart Nano Mater 2020; 11: 343–369.

21.

Bae

Chang

. Characterization of an electroactive polymer (PVDF-TrFE) film-type sensor for health monitoring of composite structures. Compos Struct 2015; 131: 1090–1098.

22.

Shen

Chen

Zhang

, et al. Direct-write piezoelectric ultrasonic transducers for non-destructive testing of metal plates. IEEE Sensors J 2017; 17: 3354–3361.

23.

Chen

Wong

Zhang

, et al. Monitoring of cracks near fastener holes using direct-write ultrasonic transducers. Eng Res Express 2020; 2: 015019.

24.

Guo

Chen

Zhang

, et al. Design and fabrication of direct-write piezoelectric ultrasonic transducers for determining yielding of aluminum alloy. NDT E Int 2018; 98: 186–194.

25.

Schmidt

Sinapius

Wierach

. Design of mode selective actuators for Lamb wave excitation in composite plates. CEAS Aeronaut J 2013; 4: 105–112.

26.

Philibert

Chen

Wong

, et al. Direct-write piezoelectric transducers on carbon-fiber-reinforced polymer structures for exciting and receiving guided ultrasonic waves. IEEE Trans Ultrason Ferroelectrics, Freq Control 2021; 68: 2733–2740. DOI: 10.1109/TUFFC.2021.3073131.

27.

Gresil

Giurgiutiu

. Prediction of attenuated guided waves propagation in carbon fiber composites using rayleigh damping model. J Intell Mater Syst Structures 2015; 26: 2151–2169.

28.

Ong

Rajic

Chiu

, et al. Determination of the elastic properties of woven composite panels for lamb wave studies. Compos Struct 2016; 141: 24–31.

29.

Belingardi

Vadori

. Low velocity impact tests of laminate glass-fiber-epoxy matrix composite material plates. Int J Impact Eng 2002; 27: 213–229.

30.

Fromme

. Influence of guided ultrasonic wave scattering directionality on the detection sensitivity for SHM of fatigue cracks. In: Proc. SPIE, health monitoring of structural and biological systems, San Diego, 8 April 2010, p. 76501M.

31.

Irving

Soutis

. Polymer composites in the aerospace industry. 2nd ed. Matthew Deans: Elsevier, 2020. DOI: 10.1016/b978-0-08-102679-3.01001-7.

32.

Dorado

Moore

. Composite material characterization using acoustic wave speed measurements. In: ASNT annual conference Salt Lake, UT, USA, 26 October 2015.

33.

Perez

Gil

Oller

. Non-destructive testing evaluation of low velocity impact damage in carbon fiber-reinforced laminated composites. Ultrasound 2011; 66: 1–10.

34.

Bian

, et al. Experimental research on detection for interface debond of CFRP T-joints under tensile load. Compos Struct 2016; 158: 359–368.

35.

Souza

Nobrega

EGO

. Lamb wave based damage detection and localization using two ring-shaped arrangement of piezo transducers. IFAC-PapersOnLine 2015; 48: 646–651.

36.

Janarthan

Mitra

Mujumdar

. Lamb wave based damage detection in composite panel. J Indian Inst Sci 2013; 93: 715–733.

37.

Monnier

. Lamb waves-based impact damage monitoring of a stiffened aircraft panel using piezoelectric transducers. J Intell Mater Syst Structures 2006; 17: 411–421.

38.

Truong

Kang

Lee

, et al. Comparative study of laser doppler vibrometer and capacitive air-coupled transducer for ultrasonic propagation imager and the new development of an efficient ultrasonic wavenumber imaging algorithm. Strain 2015; 51: 332–342.