Homogeneous charge compression ignition versus dual fuelling for utilizing biogas in compression ignition engines

Abstract

In this work, biogas was used in a compression ignition (CI) engine in the homogeneous charge compression ignition (HCCI) mode as well as in the dual-fuel mode together with diesel. In the HCCI mode, the charge temperature and amount of diesel injected into the intake manifold were used to control combustion. The presence of carbon dioxide in biogas suppresses the high heat release rates normally encountered in neat-diesel-fuelled HCCI engines. Efficiencies close to diesel operation together with extremely low levels of nitric oxide (NO) and smoke were attained in a brake mean effective pressure (BMEP) range from 2.5bar to 4bar in the biogas—diesel homogeneous charge compression ignition (BDHCCI) mode. Proper control over the charge temperature was essential. Thermal efficiency was higher and NO, hydrocarbon, carbon monoxide, and smoke levels were lower than in the biogas—diesel dual-fuel mode. Thus, the BDHCCI mode is a viable option for using biogas in CI engines in the medium-load ranges. Operation of the engine in the CI mode with diesel below a BMEP of 2.5bar, then in the HCCI mode up to a BMEP of 4bar, and in the dual-fuel mode at higher BMEPs could lead to good overall performance and low emissions.

Keywords

biogas dual fuel homogeneous charge compression ignition engine alternative fuels nitrogen oxide control

Get full access to this article

View all access options for this article.

References

Porpatham

Experimental investigations on a biogas fuelled SI engine PhD Thesis, Indian Institute of Technology, Madras, India, 2008.

Porpatham

Ramesh

Nagalingam

‘Investigation on the effect of concentration of methane in biogas when used as a fuel for a spark ignition engine.’

Fuel 87 (8–9) (2008): 1651–1659

Porpatham

Ramesh

Nagalingam

‘Effect of hydrogen addition on the performance of a biogas fuelled spark ignition engine.’

Int. J. Hydrogen Energy 32 (2007): 2057–2065

Bari

‘Effect of carbon dioxide on the performance of biogas/diesel dual fuel engine.’

Int. J. Renewable Energy 9 (3) (1996): 1007–1110

Prakash

Ramesh

Tazerout

‘Influence of injection timing and load on the performance and combustion characteristics of a biogas/diesel dual fuel engine.’

Fuels Int. 1 (3) (2001): 229–243

Narayana Reddy

Experimental investigations on a biodiesel fuelled CI engine MS Thesis, Indian Institute of Technology, Madras, India, 2006.

Poonia

M. P.

Ramesh

Gaur

R. R.

‘Experimental investigation of the factors affecting the performance of a LPG dual fuel engine.’ SAE paper 1999–01-1123, 1999

Onishi

S. H.

Shoda

P. D.

Kato

‘Active thermo-atmospheric combustion (ATAC) — a new combustion process for internal combustion engines.’ SAE paper 790501, 1979.

Najt

P. M.

Foster

D. E.

‘Compression-ignited homogeneous charge combustion.’ SAE paper 830264, 1983

10.

Ryan

T. W.

Callahan

T. J.

‘Homogeneous charge compression ignition (HCCI) of diesel fuel.’ SAE paper 961160, 1996.

11.

Swami Nathan

Mallikarjuna

J. M.

Ramesh

Effect of coolant and charge temperatures in a manifold injected premixed charge compression ignition engine — an experimental study. In Proceedings of the International Conference on

IC engines and combustion, Hyderabad, India

12.

Shigeyuki

Ayala

James

C. K.

Heywood

J. B.

‘Two-stage ignition in HCCI combustion and HCCI control by fuels and additives.’

Combust. Flame 132 (2003): 219–239

13.

Chen

Konno

Goto

‘Study on homogenous premixed charge CI engine fueled with LPG.’

JSAE Rev. 22 (2001): 265–270

14.

Kim

D. S.

Lee

C. S.

‘Improved emission characteristics of HCCI engine by various premixed fuels and cooled EGR.’

Fuel 85 (2006): 695–704

15.

Sahashi

Azetsu

Oikawa

‘Effects of N₂/CO₂ addition on ignition and combustion in homogeneous charge compression ignition engine operated on dimethyl ether.’ In Proceedings of the Sixth International Conference on Modeling and diagnostics for advanced engine systems (COMODIA 2004), Yokohama, Japan

16.

Swami Nathan

Mallikarjuna

J. M.

Ramesh

‘Effect of adding N₂ and CO₂ on control of combustion in a manifold injected homogeneous charge compression ignition engine — an experimental study.’ In Proceedings of the 2008 IEEE International Conference and Expo on Multimedia (ICME 2008), Johur Bahru, Malaysia, 2008, pp. 51–53 (IEEE, New York).

17.

18.

Glassman

Combustion, 3rd edition (: Academic Press 1996) (Academic Press, London).