Laboratory and Field Evaluation of Cement Kiln Dust and Lime for Stabilizing Clayey Silt on Low-Volume Unpaved Roads

Abstract

The potential of cement kiln dust (CKD) and lime (quicklime) for stabilizing low-volume unpaved roads on sites dominated by cohesive soils was investigated. CKD, lime plus CKD, lime, and portland cement were tested at different mixtures and soil moisture contents in a clayey silt to determine the resulting unconfined compressive strength after three curing periods. In a field study, road sections were stabilized with CKD and with lime plus CKD, and then a gravel running surface was added. Soil penetration resistance increased after the treatment. Field results confirmed the laboratory results and helped identify the most effective treatment. Stabilization proved cost-effective for new roads in areas where gravel is difficult to obtain.

Get full access to this article

View all access options for this article.

References

Légère

Stabilization of Clays Using Lime: Opportunities for Forestry Road Construction. In Proc., Annual Conference, Edmonton, Alberta. Transportation Association of Canada, Ottawa, Ontario, 2000.

Légère

Étude technico-économique de la stabilisation à la chaux des sols argileux en voirie forestière (in French). Master’s of Engineering thesis. École de Technologie Supérieure, Université du Québec, Montreal, Canada, 2001.

Bell

F. G.

The Influence of the Mineral Content of Clays on Their Stabilisation by Cement. Bulletin of the International Association of Engineering Geology, Vol. 13, No. 3, 1976, pp. 267–278.

Diamond

, White

J. L.

, and Dolch

W. L.

. Mechanisms of Soil-Lime Stabilization. Highway Research Record No. 92, HRB, National Research Council, Washington, D.C., 1965, pp. 83–102.

Choquette

, Bérubé

M.-A.

, and Locat

. Mineralogical and Microtextural Changes Associated with Lime Stabilization of Marine Clays from Eastern Canada. Applied Clay Science, Vol. 2, 1987, pp. 215–232.

Foscal-Mella

Analyse Minéralogique des Argiles Glaciaires (in French). Master’s thesis. École Polytechnique, Montréal, Québec, Canada, 1976.

Little

D. N.

Evaluation of Structural Properties of Lime Stabilized Soils and Aggregates. Volume 1: Summary of Findings. National Lime Association, Arlington, Va., 1999.

Holt

C. C.

, and Freer-Hewish

R. J.

. Lime Treatment of Capping Layers in Accordance with the Current Specification for Highway Works. In Proc., Seminar on Lime Stabilisation, Loughborough University, Thomas Telford, London, 1996, pp. 51–61.

Broms

B. B.

, and Boman

. Stabilization of Soil with Lime Column. In Design Handbook, Royal Institute of Technology, Stockholm, Sweden, 1977.

10.

Kennedy

T. W.

, Smith

, Holmgreen

R. J.

, Jr., and M. Tahmoressi. An Evaluation of Lime and Cement Stabilization. In Transportation Research Record No. 1119, TRB, National Research Council, Washington, D.C., 1987, pp. 11–25.

11.

Tremblay

Amélioration Mécanique et Prédiction de la Compressibilitédes Sols Fins du Québec. Ph.D. thesis. Université Laval, Québec, Québec, Canada, 1998.

12.

Perry

, Snowdon

R. A.

, and Wilson

P. E.

. Site Investigation for Lime Stabilisation in the United Kingdom. Cement Lime and Gravel, Vol. 42, No. 9, 1995, pp. 277–280.

13.

Smith

J. H.

Construction of Lime or Lime Plus Cement Stabilised Cohesive Soils. Proc., Seminar on Lime Stabilisation, Loughborough University, Thomas Telford, London, 1996, pp. 13–26.

14.

Little

D. N.

Handbook for Stabilization of Pavement Subgrades and Base Courses with Lime. National Lime Association, Arlington, Va., 1995.

15.

Users Guide for the Dynamic Cone Penetrometer. Minnesota Department of Transportation, Office of Materials Research and Engineering, Physical Research Section, St. Paul, 1993.

16.

Haynes

B. W.

, and Kramer

G. W.

. Characterization of U.S. Cement Kiln Dust. Information Circular 8885. U.S. Bureau of Mines, Avondale Research Center, Md., 1981.