Quantifying Aerosol Delivery in Simulated Spontaneously Breathing Patients With Tracheostomy Using Different Humidification Systems With or Without Exhaled Humidity

Abstract

BACKGROUND:

Aerosol and humidification therapy are used in long-term airway management of critically ill patients with a tracheostomy. The purpose of this study was to determine delivery efficiency of jet and mesh nebulizers combined with different humidification systems in a model of a spontaneously breathing tracheotomized adult with or without exhaled heated humidity.

METHODS:

An in vitro model was constructed to simulate a spontaneously breathing adult (tidal volume, 400 mL; breathing frequency, 20 breaths/min; inspiratory-expiratory ratio, 1:2) with a tracheostomy using a teaching manikin attached to a test lung through a collecting filter (Vital Signs Respirgard II). Exhaled heat and humidity were simulated using a cascade humidifier set to deliver 37°C and >95% relative humidity. Albuterol sulfate (2.5 mg/3 mL) was administered with a jet nebulizer (AirLife Misty Max) operated at 10 L/min and a mesh nebulizer (Aeroneb Solo) using a heated pass-over humidifier, unheated large volume humidifier both at 40 L/min output and heat-and-moisture exchanger. Inhaled drug eluted from the filter was analyzed via spectrophotometry (276 nm).

RESULTS:

Delivery efficiency of the jet nebulizer was less than that of the mesh nebulizer under all conditions (P < .05). Aerosol delivery with each nebulizer was greatest on room air and lowest when heated humidifiers with higher flows were used. Exhaled humidity decreased drug delivery up to 44%.

CONCLUSIONS:

The jet nebulizer was less efficient than the mesh nebulizer in all conditions tested in this study. Aerosol deposition with each nebulizer was lowest with the heated humidifier with high flow. Exhaled humidity reduced inhaled dose of drug compared with a standard model with nonheated/nonhumidified exhalation. Further clinical research is warranted to understand the impact of exhaled humidity on aerosol drug delivery in spontaneously breathing patients with tracheostomy using different types of humidifiers.

Keywords

aerosols nebulizers humidification drug delivery and tracheostomy

Get full access to this article

View all access options for this article.

References

Dhand

. Special problems in aerosol delivery: artificial airways. Respir Care, 2000; 45(6):636–645.

Dhand

, Guntur

. How best to deliver aerosol medications to mechanically ventilated patients. Clin Chest Med. 2008; 29(2):277–296, vi.

Dhand

, Mercier

. Effective inhaled drug administration to mechanically ventilated patients. Expert Opin Drug Deliv, 2007; 4(1):47–61.

Berlinski

. Nebulized albuterol delivery in a model of spontaneously breathing children with tracheostomy. Respir Care, 2013; 58(12):2076–2086.

Berlinski

, Chavez

. Albuterol delivery via metered dose inhaler in a spontaneously breathing pediatric tracheostomy model. Pediatr Pulmonol, 2013; 48(10):1026–1034.

Pitance

, Vecellio

, Delval

, Reychler

, Liistro

. Aerosol delivery through tracheostomy tubes: an in vitro study. J Aerosol Med Pulm Drug Deliv, 2013; 26(2):76–83.

Ari

, Fink

, Dhand

. Inhalation therapy in patients receiving mechanical ventilation: an update. J Aerosol Med Pulm Drug Deliv, 2012; 25(6):319–332.

Ari

. Aerosol drug delivery in critical pulmonary care. Respir Care. 2015; 60(6):858–874; discussion 874-879.

Ari

, Harwood

, Sheard

, Fink

. An in vitro evaluation of aerosol delivery through tracheostomy and endotracheal tubes using different interfaces. Respir Care, 2012; 57(7):1066–1070.

10.

Ari

, Harwood

, Sheard

, Dailey

, Fink

. In vitro comparison of heliox and oxygen in aerosol delivery using pediatric high flow nasal cannula. Pediatr Pulmonol, 2011; 46(8):795–801.

11.

Perry

, Kesser

, Geller

, Selhorst

, Rendle

, Hertzog

. Influences of cannula size and flow rate on aerosol drug delivery through the Vapotherm humidified high-flow nasal cannula system. Pediatr Crit Care Med, 2013; 14(5):e250–e256.

12.

Ari

, Areabi

, Fink

. Evaluation of position of aerosol device in two different ventilator circuits during mechanical ventilation. Respir Care, 2010; 55(7):837–844.

13.

Ari

, Telli

, Harwood

, Sheard

, Fink

. Influence of nebulizer type, position and bias flow on aerosol drug delivery in simulated pediatric and adult lung models during mechanical ventilation. Respiratory Care, 2010; 55(7):845–851.

14.

Lange

, Finlay

. Overcoming the adverse effect of humidity in aerosol delivery via pressurized metered-dose inhalers during mechanical ventilation. Am J Respir Crit Care Med, 2000; 161(5):1614–1618.

15.

Lin

, Fink

, Zhou

, Cheng

. Influence of moisture accumulation in inline spacer on delivery of aerosol using metered-dose inhaler during mechanical ventilation. Respir Care, 2009; 54(10):1336–1341.